Loading...
HomeMy WebLinkAboutPhysical Science BuildingHALLAM - ICS PROJECT #17467.000DRAWING LIST GENERAL ARCHITECTURAL MECHANICAL PLUMBING/PIPING FIRE PROTECTION GAS MONITORING ELECTRICAL CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYT0.0COVER SHEET AND DRAWING LIST FD FCO A.8BCDC.2 A.6 1 CODE AND EGRESS PROPOSED PLANBASEMENT - CODE AND EGRESS PLAN PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYOCCUPANCY ORIGINAL CONSTRUCTION DOCUMENTS Based on the Building Code of New York State Use Group A-3 (Assembly) Lobby, Classrooms with 50 or more Occupants, Conference Rooms, Atrium Spaces Use Group B (Business) Laboratories, Offices, Classrooms with less than 50 Occupants Use Group S-2 (Low Hazard Storage) Storage Rooms and Mechanical Rooms CONSTRUCTION - TYPE 1B Exterior Walls (NYSBC 704.5) Load Bearing Exterior Walls Non-Load Bearing Exterior Walls separating Atrium from unsprinklered areas Non-Load Bearing Exterior Walls separating Atrium from sprinklered areas if provided FIRE RESISTANCE REQUIREMENTS (in Hours) 2 2 2 Fire Separation Assemblies (BCNYS 707) Shafts and Exit Enclosures (< four stories) Shafts and Exit Enclosures (4 or more stories) 1 2 Fire/Smoke Partitions NCExit access corridors Interior Bldg. Walls & Partitions, columns, girders, trusses (other than roof trusses), and framing 2 Structural Members Supporting FRR Walls/Floors/Ceilings 2 Floor Consturction including Beams 1 2 Roof Construction, including Beams, trusses and framing, arches, and Roof deck NC Roof Construction (< 20- feet above the Floor Below) Roof Construction (20- feet above the Floor Below) NC - non-combustible FIRE RESISTANCE RATED SEPARATIONS & ENCLOSURES Transformers and transformer vaults (NEC)2 hours Emergency generator room Fire pump room (NFPA 2-7.1.1) Storage rooms greater than 100 square feet Physical plant maintenance workshops Atrium separations and supporting construction 2 hours 1 hour with AS SP 1 hour or AS and SPs 2 hour AS - Automatic Suppression, SP - Smoke partitions CONTROL AREA SEPARATIONS Floor Ceiling Assemblies (NYSBC 414.2.3)2 hours Wall Assemblies on Levels Sb-2 (NYSBC T-414.2.2) Wall Assemblies on Levels 3-4 (NYSBC T414.2.2) Structural Members Supporting Control Area Floors/Ceilings Structural Members Supporting Control Area Walls on Levels SB-2 Structural Members Supporting Control Area Walls on Levels 3-4 1 hour 2 hours 2 hours 2 hour 2 hours (as amended from the 2000 International Building Code) Non-Load Bearing Exterior Walls with a fire separation distance of less than five (5) feet Non-Load Bearing Exterior Walls with a fire separation between 10 and 30 feet Non-Load Bearing Exterior Walls with a fire separation greater than 30 feet 1 2 NC Use Group H-2 & H-3 (High Hazard Storage) Storage Rooms TOTAL LAB (B87) CONQUEST/MOORE OCCUPANCY LOAD Factor (sf/Occ)Area (sf) Load (Occ) 100990 101148 0 10 Group B SERVICE CHASE (B87A)158 0 TOTAL Factor (sf/Occ)Area (sf) Load (Occ) OCCUPANCY CONQUEST PROJECT CONSTRUCTION DOCUMENTS Based on the Building Code of New York State Use Group B (LABORATORIES) CONSTRUCTION - TYPE 1B Exterior Walls (NYSBC 704.5) Load Bearing Exterior Walls Non-Load Bearing Exterior Walls FIRE RESISTANCE REQUIREMENTS (in Hours) 2 2 Interior Bldg. Walls & Partitions, columns, girders, trusses (other than roof trusses), and framing 2 Structural Members Supporting FRR Walls/Floors/Ceilings 2 Floor Consturction including Beams 2 NC - non-combustible FIRE RESISTANCE RATED SEPARATIONS & ENCLOSURES Laboratory to Corridor 2 hours Laboratory to Service Chase NR AS - Automatic Suppression, SP - Smoke partitions CONTROL AREA SEPARATIONS Floor Ceiling Assemblies (NYSBC 414.2.3)2 hours Wall Assemblies on Levels Sb-2 (NYSBC T-414.2.2) Wall Assemblies on Levels 3-4 (NYSBC T414.2.2) Structural Members Supporting Control Area Floors/Ceilings Structural Members Supporting Control Area Walls on Levels SB-2 Structural Members Supporting Control Area Walls on Levels 3-4 1 hour 2 hours 2 hours 2 hour 2 hours (as amended from the 2012 NEW YORK Building Code) EXIT CAPACITY Stair No. 1 Width (in.) Factor (in/Per) Capacity (Per) 48 0.20 240 ----- TOTAL Offices and Labs ORIGINAL OCCUPANCY LOAD Factor (sf/Occ)Area (sf) Load (Occ) 10022,630 36135,304* 680 > 361 653 44 100 227 15 Stair No. 3 44 0.20 220 Group B Circulation 7,201 Group A-3 Utility Tunnel Group S-2 Mechanical and Data 3,238 1,582 300 300 73 11 6 Stair No. 5 44 0.20 220 EXIT CAPACITY TOTAL Width (in.) Factor (in/Per) Capacity (Per) 136 TOTAL Factor (sf/Occ)Area (sf) Load (Occ) 300 300 Breakout and Conf. *LESS THAN GSF. REFER TO ORIGINAL CONSTRUCTION PROJECT DD REPORT FOR NET & GROSS BLDG. AREAS BUILDING CODE OF NEW YORK STATE, 2010 MECHANICAL CODE OF NEW YORK STATE, 2010 PLUMBING CODE OF NEW YORK STATE, 2010 FIRE CODE OF NEW YORK STATE, 2010 STANDARD ON FIRE PROTECTION FOR LABORATORIES USING CHEMICALS, NFPA 45, 2011 NATIONAL ELECTRICAL CODE, NFPA 70 2008 CORNELL UNIVERSITY DESIGN AND CONSTRUCTION STANDARDS STATUTORY CODES AND VOLUNTARY STANDARDS PROPOSED CHEMICAL STORAGE BASED ON 2010 EXISTING BUILDING CODE OF NEW YORK STATE, THIS PROJECT IS A LEVEL TWO ALTERCATION A1.0 4 A1.0 3 A5.0 1 A5.0 2 SCALE: 1/4" = 1'-0" SCALE: 1/4" = 1'-0"SCALE: 3/8" = 1'-0" SCALE: 3/8" = 1'-0"CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 DEMOLITION AND PROPOSED PLANMA WEN 802-923-3088WWW.HINGEINCVT.COM182 MAIN STREET, 2ND FL. BURLINGTON, VTJ:\Project_ENG\17467.000 CORNELL,CONQUEST-Moore\Drawings\A1.0.dwg Thursday, June 04, 2015 4:49:39 PM djk FD FCO A.8BCDC.2 A.6 2 1 GENERAL ARRANGEMENT PROPOSEDBASEMENT - GENERAL ARRANGEMENT PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITY A3.0 3 SCALE: 1" = 1'-0"SCALE: 1" = 1'-0"SCALE: 3" = 1'-0"SCALE: 1 1/2" = 1'-0"CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 WALL SECTION PROPOSEDMA WEN 802-923-3088WWW.HINGEINCVT.COM182 MAIN STREET, 2ND FL. BURLINGTON, VTJ:\Project_ENG\17467.000 CORNELL,CONQUEST-Moore\Drawings\A3.0 - WALL SECTION.dwg Thursday, June 04, 2015 4:50:05 PM djk A.8BCDC.2 A.6 2 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYOVERHEAD CRANE PLAN PROPOSED BASEMENT - OVERHEAD CRANE PLAN PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYB87 - NORTH ELEVATION B87 NORTH ELEVATION CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYB87A - SERVICE CLOSET ELEVATION B87A SERVICE CLOSET ELEVATION A.8BCDC.2 A.6 2 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYCABLE TRAY/CONDUIT LAYOUTBASEMENT - CABLE TRAY/CONDUIT LAYOUT DOOR SCHEDULE DOOR NO.TYPE DOOR HDWR FRAME COMMENTSW H TH. MAT'L FIN. MAT'L FIN. 100 B 6' - 0" 6' - 10" 2" WOOD POLYURETHANE SET A METAL PAINT 45 MINUTE RATED DOOR 101 A 6' - 0" 7' - 0" 1 3/4" METAL PAINT SET B METAL PAINT HINGES TO OPEN 180 DEGREES 102 A 6' - 0" 7' - 0" 1 3/4" METAL PAINT SET B METAL PAINT HINGES TO OPEN 180 DEGREES 103 A 6' - 0" 7' - 0" 1 3/4" METAL PAINT SET B METAL PAINT HINGES TO OPEN 180 DEGREES 104 A 6' - 0" 7' - 0" 1 3/4" METAL PAINT SET B METAL PAINT HINGES TO OPEN 180 DEGREES 105 A 6' - 0" 7' - 0" 1 3/4" METAL PAINT SET B METAL PAINT HINGES TO OPEN 180 DEGREES 106 EXISTING 4' - 8" 7' - 0" 1 3/4"REMOVE EXISTING DOOR AND FRAME SALVAGE FOR OWNER 107 EXISTING 4' - 8" 7' - 0" 1 3/4"REMOVE EXISTING DOOR AND FRAME SALVAGE FOR OWNER 108 EXISTING 3' - 0" 7' - 0" 1 3/4"REMOVE EXISTING DOOR AND FRAME SALVAGE FOR OWNER ROOM FINISH SCHEDULE ROOM # NAME FLOOR BASE WALL FINISH DOOR FRAMES CEILING COMMENTSNORTH SOUTH EAST WEST MAIN B87 LAB RESILENT TILE RESILANT BASE PAINT PAINT PAINT PAINT PAINT PAINT CIELING PAINT IS FOR TOUCH UP, NOT A WHOLESALE REPAINTING. TOUCH UP PAINT ON EAST WALL. REPAINT ENTIRE WEST WALL. B87A LAB CLOSET RESILENT TILE RESILANT BASE PAINT PAINT PAINT PAINT PAINT PAINT SCALE: 1 1/2" = 1'-0"SCALE: 1 1/2" = 1'-0"SCALE: 3" = 1'-0"SCALE: 3" = 1'-0"CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 SCHEDULESMA WEN 802-923-3088WWW.HINGEINCVT.COM182 MAIN STREET, 2ND FL. BURLINGTON, VTJ:\Project_ENG\17467.000 CORNELL,CONQUEST-Moore\Drawings\A5.0.dwg Thursday, June 04, 2015 4:51:00 PM djk CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEQUIPMENT LIST (1/2)Hex EQUIPMENT INFORMATION EQUIPMENT NAME:LOCATION: SUPPLIED BY: RIGGED AND MOUNTED BY:Company:Model: 1 MBE #1 MBE Lab B87 OWNER CONTRACTOR Veeco Gen10 2 MBE #1 Electronics Rack MBE Lab B87 OWNER CONTRACTOR Veeco - 3 MBE #2 MBE Lab B87 OWNER CONTRACTOR Veeco Gen10 4 MBE #2 Electronics Rack MBE Lab B87 OWNER CONTRACTOR Veeco - 5 Maple Top Table 30x72 (Qty 7)MBE Lab B87 OWNER CONTRACTOR Lista - 6 E-Beam Gun MBE Lab B87 OWNER CONTRACTOR Veeco - 6A E-Beam Power Supply MBE Lab B87 OWNER CONTRACTOR Veeco - 6B Robot/cluster module MBE Lab B87 OWNER CONTRACTOR Veeco - 7 Wet Bench MBE Lab B87 CONTRACTOR CONTRACTOR Reynoldstech - 8 Desiccator MBE Lab B87 OWNER CONTRACTOR Terra Universal Smart Desiccator 1911-02C 8a Desiccator MBE Lab B87 OWNER CONTRACTOR Terra Universal Smart Desiccator 1911-02C 9 Desiccator MBE Lab B87 OWNER CONTRACTOR Terra Universal Smart Desiccator 1911-02C 9a Desiccator MBE Lab B87 OWNER CONTRACTOR Terra Universal Smart Desiccator 1911-02C 10 Desiccator MBE Lab B87 OWNER CONTRACTOR Terra Universal Smart Desiccator 1911-02C 11 Storage Cabinets (Qty of 6)MBE Lab B87 OWNER CONTRACTOR Lista various 12 Bridge Crane MBE Lab B87 CONTRACTOR CONTRACTOR Budgit - 13 O3/O2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR -- 14 Ozone Generator Service Chase CONTRACTOR CONTRACTOR MKS/SEMOZON AX 8407C -3 15 O3/O2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR -- 16 Ozone Generator Service Chase CONTRACTOR CONTRACTOR MKS/SEMOZON AX 8407C -3 16a Ozone Controller Electronic Rack Ozone Rack CONTRACTOR CONTRACTOR MKS/SEMOZON - 16b Ozone Destruct Service Chase CONTRACTOR CONTRACTOR -- 17 Vacuum Pumping Station - Portable MBE Lab B87 OWNER OWNER -- 18 MBE Control Computer MBE Lab B87 OWNER CONTRACTOR Veeco - 19 MBE Data Computer MBE Lab B87 OWNER CONTRACTOR Veeco - 20 MBE Other Computer MBE Lab B87 OWNER CONTRACTOR Veeco - 21 Cryo Pump 1 (Cooled by 60)ARPES OWNER OWNER Brooks Cryo-Torr 8 22 Turbo Pump 1 (Backed by 63)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 23 NEG Pump 1 ARPES OWNER OWNER Saes Capacitorr D-2000 24 He Lamp ARPES OWNER OWNER VG Scienta VUV5000 25 Microwave generator Rack 2 (Sources/Measurement)OWNER OWNER VG Scienta VUV5000 26 X-Ray Source has rack mounted UPS Rack 2 (Sources/Measurement)OWNER OWNER Specs AXR-50 27 HR-EELS Gun Rack 2 (Sources/Measurement)OWNER OWNER ARS LK5000M 28 Sclents R8000 Electron Analyzer Rack 2 (Sources/Measurement)OWNER OWNER VG Scienta R-8000 29 Closed Cycle Cryostat (CCC) 1 (cooled by 67)ARPES OWNER OWNER ARS CS204(P?)B 30 XYZ Stage see item 31 ARPES OWNER OWNER McAllister - 31 Manipulator Mk-V / Motors Rack 1 (LEED/ARPES Control)OWNER OWNER -- 32 RGA ARPES OWNER OWNER SRS RGA 100 33 Ion Gauge/Controllers (x3)Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 34 ARPES/LEED Control Computer MBE Lab B87 OWNER OWNER -- 35 ARPES/LEED Data Computer MBE Lab B87 OWNER OWNER -- 36 Cryo Pump 2 (Cooled by 61)LEED OWNER OWNER Brooks Cryo-Torr 8 37 Turbo Pump-2 (Backed by 64)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 38 NEG Pump-2 LEED OWNER OWNER Saes Capacitorr D-2000 39 ErLEED Rack 2 (Sources/Measurement)OWNER OWNER Specs ErLEED 100 40 RGA LEED OWNER OWNER SRS SRS 100 41 lonGauge/Controllers (x1)Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 42 Closed Cycle Cryostat (CCC) 2 (cooled by 68)LEED OWNER OWNER ARS CS204(P?)B 43 XYZ Stage LEED OWNER OWNER McAllister - 44 Manipulator Mk-VI / Motors Rack 1 (LEED/ARPES Control)OWNER OWNER Custom - 45 Roots Pump Service Chase OWNER OWNER -- 46 Data Acquisition Computer MBE Lab B87 OWNER OWNER -- 47 Mission Critical Laptop MBE Lab B87 OWNER OWNER -- 48 Cryo Pump 3 (Cooled by 62)IPES OWNER OWNER Brooks Cryo-Torr 8 49 Turbo Pump 3 (Backed by 64)Rack 3 (IPES)OWNER OWNER Pfeiffer Hi-Pace 700M 50 NEG Pump 3 IPES OWNER OWNER Saes Capacitorr D-2000 51 Cube Pump (Backing Turbo)IPES OWNER OWNER -- 52 Electron Gun Rack 3 (IPES)OWNER OWNER Kimball ELG-2/EGPS-1022 53 UPS Rack 3 (IPES)OWNER OWNER -- 55 Ion Gauge/Controllers (x1)Rack 3 (IPES)OWNER OWNER Brooks - 56 Temperature Controller/Heater Rack 3 (IPES)OWNER OWNER -- 57 RGA (IPES)Rack 3 (IPES)OWNER OWNER SRS SRS 100 58 Manipulator Mk-IV/Motors/xyz stage Rack 3 (IPES)OWNER OWNER -- 59 Bake out oven (tent)Lab OWNER OWNER -- 60 Cryo 1 Compressor (cools 21)Service Chase OWNER OWNER Brooks CTI 8200 61 Cryo 2 Compressor (cools 36)Service Chase OWNER OWNER Brooks CTI 8200 62 Cryo 3 Compressor (cools 48)Service Chase OWNER OWNER Brooks CTI 8200 63 Turbo 1 Backing Pump (cube pump) (Backs 22) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 64 Turbo 2 Backing Pump (cube Pump) (Backs 37) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 65 Turbo 3 Backing Pump (cube Pump) (Backs 49) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 66 Mono Turbo Pump (needs backing pump) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 300 67 CCC Compressor 1 (ARPES) (cools 29)Service Chase OWNER OWNER ARS ARS-4HW 68 CCC Compressor 2 (LEED) (cools 42)Service Chase OWNER OWNER ARS ARS-4HW 69 CCC Compressor 3 (IPES) (cools 69)Service Chase OWNER OWNER ARS ARS-4HW 71 Vacuum Pump - O3/O2 Gas Cabinet - Primary MBE 1 Service Chase OWNER CONTRACTOR Adixen ACP28G 72 Vacuum Pump - O3/O2 Gas Cabinet - Backup MBE 1 Service Chase OWNER CONTRACTOR Adixen ACP28G 73 Vacuum Pump - O3/O2 Gas Cabinet - Primary MBE 2 Future Service Chase OWNER CONTRACTOR Adixen ACP28G 74 Vacuum Pump - O3/O2 Gas Cabinet - Backup MBE 2 Future Service Chase OWNER CONTRACTOR Adixen ACP28G 75 Cryo Compressor - cooling O3 cabinet Service Chase OWNER OWNER ARS ARS-4HW CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEQUIPMENT LIST (2/2)Hex EQUIPMENT INFORMATION EQUIPMENT NAME:LOCATION: SUPPLIED BY: RIGGED AND MOUNTED BY: Company:Model: 76 Cryo Compressor - cooling O3 cabinet Service Chase OWNER OWNER ARS ARS-4HW 77 Rough Vacuum Pump - MBE #1 Main Turbo Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 78 Rough Vacuum Pump - MBE #1 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 79 Rough Vacuum Pump - MBE #1 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 81 Rough Vacuum Pump - MBE #2 Main Turbo Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 82 Rough Vacuum Pump - MBE #2 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 83 Rough Vacuum Pump - MBE #2Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 85 Rough Vacuum Pump - ARPES First stage helium lamp Service Chase OWNER OWNER Assuming Edwards XDS-10 85a Process Chamber Vacuum Pump (backs turbopump on process chamber)Service Chase OWNER Contractor Adixen ACP28G 86 Load Lock Vacuum Pump Service Chase OWNER Contractor Edwards ESDP12 87 Cryo-Compressor 1 (Connects to MBE 1)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 88 Cryo-Compressor robot (Connects to process chamber)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 89 Cryo-Compressor 2 (Connects to MBE 2)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 90 XYZ stage 3 IPES IPES OWNER OWNER Mcalister - 91 Transfer Cart magnets and Motors Rack 1 (LEED/ARPES Control)OWNER OWNER N/A - 92 Closed Cycle Cryostat (CCC) 3 (cooled by 69)IPES OWNER OWNER ARS CS204(P?)B 93 Cryo Pump Compressor 4 (CP-4)Service Chase OWNER OWNER Brooks CTI 8200 94 Cryo Pump Compressor 5 (CP-5)Service Chase OWNER OWNER Brooks CTI 8200 95 Haskris H2O-H2O Hx Service Chase CONTRACTOR CONTRACTOR Haskris Custom 96 Inert Gas Racks (He, Ar, O2, Kr, Ne)Service Chase CONTRACTOR CONTRACTOR -- 96a Oxygen Control Panel Service Chase CONTRACTOR CONTRACTOR -- 96b Oxygen Control Panel Service Chase CONTRACTOR CONTRACTOR -- 97 DI Polisher MBE Lab B87 CONTRACTOR CONTRACTOR -- 98 H2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR Used unit - 99 Nitrogen gas supply - high purity Service Chase CONTRACTOR CONTRACTOR -- 100 Nitrogen gas supply - industrial B0063 CONTRACTOR CONTRACTOR South-Tek Systems STS N2 2T or 4T 100a High Purity Nitrogen Tank B0063 CONTRACTOR CONTRACTOR South-Tek Systems GEN 90CS 101 Nitrogen gas supply - industrial B0063 CONTRACTOR CONTRACTOR -- 102 Uninterruptable Power Supply ELEC Room CONTRACTOR CONTRACTOR -- 103 Cryo Pump - Transfer Chamber 1 CP-4 Transfer Chamber OWNER OWNER Brooks (CTI)Cryo-Torr 8 104 Cryo Pump - Transfer Chamber 2 CP-5 Transfer Chamber OWNER OWNER Brooks (CTI)Cryo-Torr 8 105 Turbo Pump Transfer Chamber 1 TP-4 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 105a Arpes Transfer Backing pump Service Chase OWNER OWNER Edwards nXDS15i 106 Turbo Pump Transfer Chamber 2 TP-5 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 107 Turbo Pump HE lamp -1 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 80m 108 Turbo Pump HE lamp -2 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 80m 109 IPES GM Tube IPES OWNER OWNER -- 110 Ion Gauge Controller Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 111 Ion Gauge Controller Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 112 Metal Evaporator 1 ME-1 ARPES OWNER OWNER -- 113 Metal Evaporator 2 ME-2 ARPES OWNER OWNER -- 114 Pirani Gauge (qty 8-10?) PG-1-X MBE Lab B87 OWNER OWNER -- 115 Webcams ( Qty.10-15)MBE Lab B87 OWNER OWNER -- 116 LED chamber Lights MBE Lab B87 OWNER OWNER -- 117 Bake Out Heater 1 BO-1 MBE Lab B87 OWNER OWNER -- 118 Bake Out Heater 2 BO-2 MBE Lab B87 OWNER OWNER -- 119 Bake Out Heater 3 BO-3 MBE Lab B87 OWNER OWNER -- 120 Bake Out Heater 4 BO-4 MBE Lab B87 OWNER OWNER -- 121 Bake out Heater Tape 1 BH-1 MBE Lab B87 OWNER OWNER -- 122 Bake out Heater Tape 2 BH-2 MBE Lab B87 OWNER OWNER -- 123 Bake out Heater Tape 3 BH-3 MBE Lab B87 OWNER OWNER -- 124 Bake out Heater Tape 4 BH-4 MBE Lab B87 OWNER OWNER -- 125 Electronics Racks (qty 3)MBE Lab B87 OWNER OWNER -- 126 MBE CHW dist. Panel MBE Lab B87 OWNER CONTRACTOR -- 126A MBE CHW dist. Panel MBE Lab B87 OWNER CONTRACTOR -- 127 STM transfer chamber roughing pump 1 B0063 OWNER OWNER Edwards nXDS15I 128 STM transfer chamber turbo pump 1 B0063 OWNER OWNER Pfeiffer HiPace 700M 129 STM transfer chamber cryo pump 1 B0063 OWNER OWNER Brooks Cryo-Torr 8 130 STM transfer chamber roughing pump 2 B0063 OWNER OWNER Edwards nXDS15I 131 STM transfer chamber turbo pump 2 B0063 OWNER OWNER Pfeiffer HiPace 700M 132 STM transfer chamber cryo pump 2 B0063 OWNER OWNER Brooks Cryo-Torr 8 133 STM transfer tube Ion gauge controllers (2x)MBE Lab B87 OWNER OWNER -- 134 STM TC Cryo Comp.1 (Cools 129)B0063 OWNER OWNER Brooks CTI 8200 135 STM TC Cryo Comp. 2 (Cools 132)B0063 OWNER OWNER Brooks CTI 8200 136 TGMS Panel MBE Lab B87 CONTRACTOR CONTRACTOR -- 137 Gas Isolation Box (GIB)MBE Lab B87 CONTRACTOR CONTRACTOR -- 138 Gas Isolation Box (GIB)MBE Lab B87 CONTRACTOR CONTRACTOR -- 139 Mono Turbo Pump backing pump Service Chase OWNER OWNER Assuming Edwards XDS-10 140 STM rotarty pump 1 B0063 OWNER OWNER Pfeiffer Duo10M 141 STM rotarty pump 2 B0063 OWNER OWNER Pfeiffer Duo10M 142 STM rotarty pump 3 B0063 OWNER OWNER Pfeiffer Duo10M 145 Scroll #3 Pump Service Chase OWNER OWNER Edwards nXDS15i 146 Scroll #5 Pump Service Chase OWNER OWNER Edwards nXDS15i 147 Scroll #6 Pump Service Chase OWNER OWNER Edwards nXDS15i 148 Super-Q Plus Water Purifier (4-bowl with pump)Lab CONTRACTOR CONTRACTOR Millipore Super-Q Plus (ZFSQ 115 P4) 149 Control Rack 1 (Leed and ARPES control)Lab OWNER OWNER Veeco - 150 Control Rack 1 (Source and Measurement)Lab OWNER OWNER Veeco - 151 Control Rack 3 (IPES Control)Lab OWNER OWNER Veeco - 152 Differential Pump Controler 1 Service Chase OWNER OWNER Veeco - 153 Differential Pump Controler 2 Service Chase OWNER OWNER Veeco - 154 Differential Pump Controler 3 Service Chase OWNER OWNER Veeco - 155 Differential Pump Controler 4 Service Chase OWNER OWNER Veeco - CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYARCHITECTURAL DETAILSB87A - UNISTRUT TABLE TYPICAL WALL MOUNTED SHELVING DETAIL B87A - GAS CYLINDER SUPPORT DETAIL B0063 - UNISTRUT TABLE ISOMETRIC BRACKET DETAIL SECTION B87 - UNISTRUT SUPPORT COLUMN B0063 - TRANSFORMER CEILING SUPPORT CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYCRANE DETAILSSWAY DETAIL HAUNCH DETAIL COLUMN DETAIL CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYMECHANICAL AND PLUMBINGLEGEND, SYMBOLSAND ABBREVIATIONSFITTINGS HVACVALVESABBREVIATIONS & SYMBOLS PIPING CONTROL LEGEND - SENSORS AND SWITCHES CONTROL DEVICES CONTROL LEGEND ABBREVIATIONS PIPING SYSTEM SPECIFICATIONS CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC DEMOLITION PROPOSEDBASEMENT - HVAC DEMOLITION PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC PIPING DEMOLITIONBASEMENT - HVAC PIPING DEMOLITION CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC PLAN PROPOSEDBASEMENT - HVAC PLAN PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC PIPING PROPOSED PLANBASEMENT - HVAC PIPING PROPOSED PLAN FD FCO A.8BCDC.2 A.6 2 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLAB PROCESS CHILLED WATER PROPOSEDBASEMENT - LAB PROCESS CHILLED WATER PROPOSED OMEGA FLOWMETER SIZING TABLE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLAB PROCESS COOLING WATER SCHEMATICLAB PROCESS COOLING WATER SCHEMATIC SCALE: NOT TO SCALE PROCESS COOLING WATER MANIFOLD AND CRYO- COMPRESSOR DETAIL SCALE: NOT TO SCALE MECHANICAL SCHEDULESCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLABORATORY AIRFLOW CONTROL VALVE SCHEDULE FAN COIL SCHEDULE FILTER HOUSING SCHEDULE PRESSURE REDUCING VALVE DIFFUSERS REGISTERS AND GRILLES CONTROL VALVE SCHEDULE WATER CHILLER - LAB EQUIPMENT CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYO3 GENERATOR CABINET DETAIL03 GENERATOR CABINET DETAIL COATING SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYWET BENCH DETAILSBASEMENT - WET BENCH DETAILS FRONT VIEW SIDE VIEW REAR VIEW DECK VIEW CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYMECHANICAL DETAILSB87A - PUMP EXHAUST DETAIL FAN COIL UNIT PIPING DETAIL TYPICAL ALL FUME HOOD EXHAUST CONNECTION DETAIL PIPE HANGER AND ROLLER DETAIL HVAC CONTROL DIAGRAMCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITY CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC CONTROL POINTS LISTSEQUENCE OF OPERATIONLABORATORY B87 CONTROL POINTS HARDWARE POINTS SOFTWARE POINTS SHOW ON GRAPHIC NOTES BI BO AI AO AV BV SCH TREND ALARM BACS EMCS DESCRIPTION STEAM LOAD SHED X BINARY NETWORK INPUT FROM EMCS CHILLED WATER LOAD SHED X BINARY NETWORK INPUT FROM EMCS TOTAL EXHAUST AIRFLOW (CFM) (B87)X X X LABORATORY B87 AIR CHANGE RATE (ACPH)X X X ROOM AREA B87 (SQUARE FEET)X X X ROOM CEILING HEIGHT (FEET) B87 X X FLOW OFFSET SETPOINT (CFM) B87 X X FLOW OFFSET ACTUAL (CFM) B87 X X X X X WET BENCH EXHAUST AIR VALVE STATUS (EV-A)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X X X X SASH OPEN 17" FOR 24 CONTINUOUS HOURS X WET BENCH EXHAUST AIR VALVE OCC/UNOCC COMMAND (EV-A)X X X X X GENERAL EXHAUST VALVE FLOW FEEDBACK (CFM) (EV-C)X X X GENERAL EXHAUST AIR VALVE STATUS (EV-C)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X GENERAL AIR VALVE OCC/UNOCC COMMAND (EV-C)X X SUPPLY AIR VALVE FLOW FEEDBACK (CFM) (SV-A)X SUPPLY AIR VALVE STATUS (SV-A)X X 10% FLOW DEVIATION FROM SETPOINT X TRI-STATE ALARM X VALVE COMMAND AND FEEDBACK MISMATCH (JAM) X LOW DIFFERENTIAL PRESSURE (VIA SWITCH) SUPPLY AIR VALVE POSITION COMMAND (CFM) (SV-A)X X X SUPPLY AIR VALVE MINIMUM AIRFLOW SETPOINT (CFM) (SV-A)X X SUPPLY AIR VALVE MAXIMUM AIRFLOW SETPOINT (CFM) (SV-A)X X REHEAT COIL LEAVING AIR TEMPERATURE (SV-A)X X X REHEAT COIL VALVE POSITION COMMAND (%) (SV-A)X X X 5 DEG F CHANGE ACROSS COIL WITH VALVE COMMANDED CLOSED X SUPPLY AIR VALVE FLOW FEEDBACK (CFM) (SV-C)X SUPPLY AIR VALVE STATUS (SV-C)X X 10% FLOW DEVIATION FROM SETPOINT X TRI-STATE ALARM X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X SUPPLY AIR VALVE POSITION COMMAND (CFM) (SV-C)X X X SUPPLY AIR VALVE MINIMUM AIRFLOW SETPOINT (CFM) (SV-C)X X SUPPLY AIR VALVE MAXIMUM AIRFLOW SETPOINT (CFM) (SV-C)X X REHEAT COIL LEAVING AIR TEMPERATURE (SVV-C)X X X REHEAT COIL VALVE POSITION COMMAND (%) (SVV-C)X X X 5 DEG F CHANGE ACROSS COIL WITH VALVE COMMANDED CLOSED X FAN COIL START/STOP (FCU-A)X X X X FAN COIL STATUS (FCU-A)X X X X X FAN COIL UNIT SPEED SIGNAL X X X X FAN COIL UNIT OPERATING SPEED X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-A)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-A)X X X X X FAN COIL START/STOP (FCU-B)X X X X FAN COIL UNIT SPEED SIGNAL X X X FAN COIL UNIT OPERATING SPEED X X X X FAN COIL STATUS (FCU-B)X X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-B)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-B)X X X X X SPACE TEMPERATURE SETPOINT, HEATING (B87)X X X SPACE TEMPERATURE SETPOINT, COOLING (B87)X X X SPACE TEMPERATURE (NORTHERN B87)X X X +/- 4 DEGREES F FROM SETPOINT X SPACE TEMPERATURE ADJUSTMENT (NORTHERN B87)X X SPACE TEMPERATURE (SOUTHERN B87)X X X +/- 4 DEGREES F FROM SETPOINT X SPACE OCCUPANCY (NORTHERN B87)X X X X SPACE OCCUPANCY (SOUTHERN B87)X X X X SPACE OCCUPANCY, MINIMUM OCCUPANCY SETPOINT (B87)X X TOTAL EXHAUST AIRFLOW (CFM) (B87A)X LABORATORY B87A AIR CHANGE RATE (ACPH)X X X ROOM 87A (SQUARE FEET)X X X ROOM CEILING HEIGHT (FEET) (B87A)X X B87A ENCLOSURE EXHAUST VALVE FLOW FEEDBACK (CFM) (EV-B)X X X B87A ENCLOSURE EXHAUST AIR VALVE STATUS (EV-B)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X B87A EXHAUST AIR VALVE OCC/UNOCC COMMAND (EV-D)X X B87A GENERAL EXHAUST VALVE FLOW FEEDBACK (CFM) (EV-D)X X X B87A GENERAL EXHAUST AIR VALVE STATUS (EV-D)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X B87A GENERAL EXHAUST AIR VALVE OCC/UNOCC COMMAND (EV-D)X FAN COIL START/STOP (FCU-C)X X X X FAN COIL STATUS (FCU-C)X X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-C)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-C)X X X X X FAN COIL START/STOP (FCU-D)X X X X FAN COIL STATUS (FCU-D)X X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-D)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-D)X X X X X CHILLER INLET PROCESS CHILLED WATER X X X MONITORING ONLY X CHILLER OUTLET PROCESS CHILLED WATER X X X MONITORING ONLY X CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC CONTROLAIRFLOW SEQUENCESMinimum Ventilation Rates Calculations Room Room Dimensions Cornell University Laboratory Standards 2010 New York State Code Minimum ASHRAE 62.1 2007 Supply Air Minimum ASHRAE 62.1 2007 Exhaust Air Minimum Occupied Airflow (8 ACH) Unoccupied Airflow (4 ACH) Occupied Airflow (6 ACH) Unoccupied Airflow (3 ACH)Hibernation Airflow Vacant AirflowArea (sq. ft.) Height (feet) Volume (cu.ft.) # of people Airflow # of people Airflow Airflow (ach) (cfm) (ach) (cfm) (ach) (cfm) (ach) (cfm) (ach) (cfm) (ach) (cfm) (cfm) (ach) (cfm) (ach) (cfm) (ach) B87 1,020 15.9 16,193 8 2,159 4 1,080 6 1,619 3 810 N/A N/A 1 270 30.6 612 2.3 25.5 439 1.6 1,020 3.8 B87A 154 16.0 2,464 8 329 4 164 6 246 3 123 N/A N/A 1 41 4.6 92 2.3 3.9 66 1.6 154 3.8 See Cornell University standard detail 3.7.1 for explanation of derivation of values shown here CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPLUMBING DEMOLITIONBASEMENT - PLUMBING DEMOLITION PROPOSEDEXISTING PLUMBING LEGEND CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPLUMBING PROPOSED PLANBASEMENT - PLUMBING PROPOSED PLAN EXISTING PLUMBING LEGEND CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYSPECIALTY GAS AND VACUUM PIPING PROPOSED PLANBASEMENT - SPECIALTY GAS AND VACUUM PIPING PROPOSED PLAN CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYOXYGEN, OZONE, HELIUM AND FORELINEMBE SCHEMATICOXYGEN, OZONE, HELIUM, AND FORELINE MBE SCHEMATIC CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYCOMPRESSED AIR AND NITROGEN FLOW DIAGRAMCOMPRESSED AIR AND NITROGEN FLOW DIAGRAM SCALE: NOT TO SCALE PLUMBING SCHEDULESCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYNITROGEN GENERATOR SCHEDULE WATER PURIFIER SCHEDULE OXYGEN CONTROL PANEL SCHEDULE GAS CYLINDER MOUNT SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPLUMBING DETAILSEXISTING FLOOR DRAIN INFILL FORELINE PIPING SUPPORT UNDER CRANE RAIL NITROGEN PIPING TO DESICCATOR DETAILTYPICAL HELIUM COMPRESSOR INSTALLATION DETAIL CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPLUMBING DETAILSNON-SCRUBBED PUMP EXHAUST DETAIL FAN COIL CONDENSATE DRAIN DETAIL FACILITY SERVICE RACK DETAIL (FOR REF. ONLY) PIPING AND INSTRUMENTATION DIAGRAMGAS CABINET DIMENSIONS GAS CABINET SCHEDULE EQUIPMENT HEX ID NUMBER LOCATION PROCESS GAS PIPING CABINET CONFIGURATION AIRFLOW (CFM)EXHAUST DUCT ELECTRICAL DIMENSIONS HOUSE GAS CONNECTIONS SAFTIES 13 B87A OZONE STILL N/A MANUAL TWO CYLINDER CABINET (EMPTY) 200 6" 110 VAC 60 Hz 3 AMP 86"T X 25"W X 23"D N/A NO WINDOW, PROOF OF VENTILATION SWITCH, SELF CLOSING DOOR, LOCKABLE, MUST MEET SEMI S2/NFPA 55 AND NY STATE FIRE CODE REQUIREMENTS, 11 GAGE CARBON STEEL, 1/4" STAINLESS STEEL HINGES, STAINLESS STEEL PADDLE LATCH (1/4" X 3/8") GAS CYINDERS PROVIDED BY OWNER 98 B87A HYDROGEN 316L EP 10Ra MAX VCR, ORBITAL WELDING FULLY-AUTOMATIC 2 CYLINDER (1 PROCESS PANEL WITH 2 OUTLETS / 1 ONBOARD PURGE) 200 6" 110 VAC 60 Hz 3 AMP 86"T X 25"W X 23"D PNEUMATIC SUPPLY COMPRESSED AIR - 1 SLPM @ 90 PSIG VACUUM MOTIVE (NOTE 1) NITROGEN - 70 SLPM @ 90 PSIG 1/4" SAFETY GLASS W/ WIRE MESH, EXCESS FLOW SWITCH, OVERPRESSURE MONITORING, COAX PIPE MONITORING, DISS FITTINGS, PURGE AND PROCESS GAS FILTER, DUAL STAGE REGULATOR, PROOF OF VENTILATION SWITCH, ONE FAIL CLOSED PNEMATIC SHUTOFF (DRY CONTACT), MUST MEET SEMI S2/NFPA 55 AND NY STATE FIRE CODE REQUIREMENTS GAS CYINDERS PROVIDED BY OWNER 1. VACUUM MOTIVE FROM ONBOARD NITROGEN PURGE. GAS MANIFOLD SCHEDULE EQUIPMENT HEX ID NUMBER LOCATION PROCESS GAS PIPING CONFIGURATION ELECTRICAL DIMENSIONS HOUSE GAS CONNECTIONS SAFTIES 96a, 96b B87A OXYGEN 316L EP 10Ra MAX VCR OR COMPRESSION FITTING, ORBITAL WELDING AUTOMATIC CHANGEOVER VIA DIFFERENTIAL PRESSURE CONTROL WITH EMERGENCY SHUTDOWN CONTROLLER 110 VAC 60 Hz 3 AMP 86"T X 25"W X 23"D PNEUMATIC SUPPLY COMPRESSED AIR - 1 SLPM @ 90 PSIG VACUUM MOTIVE COMPRESSED AIR - 70 SLPM @ 90 PSIG EXCESS FLOW SWITCH, DISS FITTINGS, PROCESS GAS FILTER, DUAL STAGE REGULATOR CAPABLE OF MAINTAINING PRESSURE AT 18-1 SLPM, TWO FAIL CLOSED PNEUMATIC SHUTOFF VALVES (DRY CONTRACT) GC-003 HYDROGEN GAS CABINET GM-001 OXYGEN GAS MANIFOLD CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYGAS CABINET DETAILS CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYFIRE PROTECION DEMOLITIONBASEMENT - FIRE PROTECTION DEMOLITION CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYFIRE PROTECTION PLAN PROPOSEDBASEMENT - FIRE PROTECTION PLAN PROPOSED PHYSICAL SCIENCES BUILDING CONQUEST-MOORE FOUNDATION TGMS NETWORK ARCHITECTURE B87 TGMS PLC SCADA SERVER CAT 6 (typical) B0042 VIEWNODE THIN CLIENT REMOTE ACCESS SERVER FIRE COMMAND CENTER PUNCHDOWN ETHERNET SWITCH FIRST FLOOR BASEMENT FIREWALL INTERNET - REMOTE ACCESS AND PAGING SCADA DISPLAY I/O - GAS DETECTION, GANS, AFS, UPS STATUS, UPS FAULT PUNCHDOWNETHERNET SWITCH MIDAS - ETHERNET CONNECTIONS FOR WEB PAGES PLC PANEL SCADA PANEL B0062 FD FCO A.8BCDC.2 A.6 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYTOXIC GAS MONITORING SYSTEMPLAN VIEWAND NETWORK CONNECTION SPSB - CONQUEST MOORE LABORATORY PLAN VIEW PSB - NETWORK CONNECTIONS AND ARCHITECTURE WOMEN G0020 STA MEN G0021 STAIR #3 G0003 ELEVATOR G0070 ELEVATOR G0071 FIRE COMMAND CENTER G01 STAIR #8 G0008 CUSTODIAL SUPPLY ROOM G0067 ULE 0 STAIR #7 G0007 FD FD UTILITY SPACE G0061 AEP LAB G31 AEP CONFERENCE G69 CORRIDOR G0041 AEP OFFICE G66 AEP OFFICE G64 AEP OFFICE G70 AEP OFFICE G03 LASSP RESEARCH FROM CLARK 2 G05 CONFERENCE G74 LASSP RESEARCH FROM CLARK 2 G07 UTILITY SPACE G0065 LASSP RESEARCH LAB FROM CLARK L2 G10 AEP LAB G06 UTILITY SPACE G0060 AEP LAB G02 CORRIDOR G0040 AEP X-RAY SCATTERING (BROCK) G67 AEP X-RAY (BROCK) G67A AEP LAB (BROCK) G73 OFFICE G72 BUILDING MANAGER CORRIDOR G0040 STORAGE G68 CORRIDOR G0040a SHARED MM OFFICE G11 REFER TO A10G FOR NOTES UTILITY SPACE B0065 UTILITY SPACE B0069 LASSP LAB B54A LASSP OFFICE B56 UTILITY SPACE B0068 DATA B78 AEP OFFICE B76 AEP LAB B74 AEP LAB B70 UTILITY SPACE B0067 AEP LAB B71 AEP LAB B75 AEP LAB B79 AEP OFFICE CORRIDOR B0041 COMMONS B92 AEP OFFICE B90 CORRIDOR B0043 LASSP LAB B56A LASSP LAB B63 LASSP LAB B62 LASSP LAB B69 LASSP LAB B66 UTILITY SPACE B0080 4 C8 A510 C8 A510A.8BCDEFF.215'-0"7'-6"22'-6"22'-6"18'-6"4'-0"22'-6"8'-0"15'-2"9'-4"9'-0"A.4A.2C.2A.64'-10"DEFF.2GHJH.62 3 3.5 4 4.7 5 24'-0"6'-6"10'-4"6'-4"10'-11" 5.1 1'-4 1/2" 3.1 2'-4"32'-2" 4.2 5'-1" 3.3 3'-2"9'-8" 3 3.5 4 4.7 5 6 7 6'-6"10'-4"6'-4"11'-3 1/2"22'-4"22'-4"10'-11" 5.1 1'-4 1/2" 3.1 2'-4" 4.2 5'-1" 3.3 3'-2"9'-8" 5.5 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYTOXIC GAS MONITORING SYSTEMAND DOOR ACCESSWIRE ROUTINGPSB - CONQUEST MOORE BASEMENT PLAN VIEWPSB - CONQUEST MOORE FIRST FLOOR PLAN VIEW CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYTOXIC GAS MONITORING SYSTEMSAFETY REQUIREMENT SPECIFICATIONPAGE 1 of 2TOXIC GAS MONITORING SYSTEM Safety Requirement Specification (SRS) Physical Science Building - B87 - "CONQUEST - Moore Foundation" Laboratory TGMS Visualization Display/s Local B0042 Corridor + Remote Fire Command Center "Green" STEADY Visual TGMS Safety OK *Green Default with no System Alarm or Trouble "White" FLASHING Visual TGMS Trouble Exhaust Fail Equipment Fault TGMS Fault "Amber" FLASHING Visual - with Horn - TGMS Equipment Enclosure (Contained) Gas Alarm "Blue" FLASHING Visual - with Horn - TGMS Ambient Gas Alarm Interlock O3 Generator Controller ID 14 SHUTDOWN Ozone -stop charging- (dry contact) Interlock O3 Generator Controller ID 16 SHUTDOWN Ozone -stop charging- (dry contact) Interlock O3 /O2 Gas Cabinet "Still" Controller ID 13 SHUTDOWN Ozone -delivery- (dry contact) Interlock O3 /O2 Gas Cabinet "Still" Controller ID 15 SHUTDOWN Ozone -delivery- (dry contact) Interlock O2 Controller/s ID 96a and ID 96b SHUTDOWN Oxygen (dry contact) Interlock H2 Controller ID 98 SHUTDOWN Hydrogen (dry contact) Interlock O3 Controllers ID 14 + ID 16 and DUMP Ozone Stills ID 13 + ID 15 (dry contacts) TGMS Gas Alarm Signaling to BMS Provide MAXIMUM Airflow Ventialtion to Laboratory TGMS "Supervisory" Ambient Breathing Gas Alarm TGMS Signaling to Fire Alarm Panel TGMS / FAS Control Area EVACUATION TGMS "Supervisory" Contained Exhaust Gas Alarm TGMS Signaling to Fire Alarm Panel (No Evacuation) TGMS "Trouble" TGMS Alarm Bypass Mode TGMS Signaling to Fire Alarm Panel Comments #Alarm Location B87 Utility Matrix Equipment ID # Alarm "Cause" Alarm Level Visualize Alarms & Origin Local Laboratory B87 LED - Light Tower Visual / Audible Notifications Automated Interlocks TGMS Signaling to BMS TGMS Signaling to FAS Ambient Breathing Zone Gas Monitoring 1 MBE-1 & MBE-2 Operator Work Area (Main MBE Room) 1 and 3 Ozone ambient breathing zone "alarm level" gas detection O3 vapor density = 1.6 (air = 1) 0.3 ppm X X X X X X X X Shutdown interlocks applied by TGMS (dry contacts) to each Ozone Generator (Utility matrix ID #14 and #16). Ozone generators (stop charging). No oxygen shutdown. Shutdown interlock also applied to both "ozone stills" (ID 13 and 15) stopping ozone delivery to the MBE tools. Activate local lab "Blue" visuals and horns for local identification of a detected "ambient" O3 gas leak condition exceeding the alarm level - initiate immediate lab evacuation. In parallel with TGMS evacuation of the laboratory, signal the fire alarm to evacuate the control area containing B87 and B87A. Fire alarm system to evacuate the control area with the TGMS evacuation audio file. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and safe alarm recovery correction/s. 2 O3 Generators and O3 "Still" Cabinets 14 and 16 ……. 13 and 15 Ozone ambient breathing zone "alarm level" gas detection O3 - Vapor density = 1.6 (air = 1) 0.3 ppm X X X X X X X X Shutdown interlock applied by TGMS (dry contact interlock) to each Ozone Generator (Utility matrix ID #14 and #16). Ozone generators (stop charging). No oxygen shutdown. Shutdown interlock also applied to both "ozone stills" (ID 13 and 15) stopping ozone delivery to the MBE tools. Activate local lab "Blue" visuals and horns for local identification of a detected "ambient" O3 gas leak condition exceeding the alarm level - initiate immediate lab evacuation. In parallel with TGMS evacuation of the laboratory, signal the fire alarm to evacuate the control area containing B87 and B87A. Fire alarm system to evacuate the control area with the TGMS evacuation audio file. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and safe alarm recovery correction/s. 3 MBE-1 & MBE-2 Operator Work Area 1 and 3 Hydrogen ambient breathing zone (detected near ceiling) "alarm level" gas detection H2 vapor density = 0.07 (air = 1) 950 ppm X X X X X Shutdown upstream Hydrogen gas cabinet. Activate "Blue" visuals and horns for local identification of a deteted laboratory "ambient" H2 gas leak detection exceeding the alarm level - initiate immediate lab evacuation. In parallel with TGMS evacuation of the laboratory, signal the fire alarm to evacuate the control area containing B87 and B87A. Fire alarm system to evacuate the control area with the TGMS evacuation audio file. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and safe alarm recovery correction/s. 4 H2 Gas Cabinet 14 and 16 ……. 13 and 15 Hydrogen ambient breathing zone (detected near ceiling) "alarm level" gas detection H2 vapor density = 0.07 (air = 1) 950 ppm X X X X X Shutdown upstream Hydrogen gas cabinet. Activate "Blue" visuals and horns for local identification of a deteted laboratory "ambient" H2 gas leak detection exceeding the alarm level - initiate immediate lab evacuation. In parallel with TGMS evacuation of the laboratory, signal the fire alarm to evacuate the control area containing B87 and B87A. Fire alarm system to evacuate the control area with the TGMS evacuation audio file. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and safe alarm recovery correction/s. Equipment / Enclosure (Contained) Gas Monitoring 5 O3 Generators Equipment Enclosure Exhaust 14 and 16 Ozone Generator Cabinets Enclosure exhaust Ozone generators ID 14 and ID 16 0.3 ppm X X X X X X Shutdown interlock applied by TGMS (dry contact interlock) to each Ozone Generator (Utility matrix ID #14 and #16). Ozone generators (stop charging). No oxygen shutdown. Activate local lab "Amber" visuals and horns to alert lab ocupants of a contained exhaust ozone hazard. Provides local identification of a detected but "contained" ozone cabinet exhaust gas leak exceeding the alarm level. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and alarm recovery correction/s. 6 Ozone "Still"13 Ozone "Still" Cabinet Exhaust 0.3 ppm X X X X X X Shutdown interlock applied by TGMS (dry contact interlock) to the upstream Ozone Generator (Utility matrix ID #14 and/or #16). Ozone generator/s (stop charging). No oxygen shutdown. TGMS shutdown interlock also applied affected to "ozone still" - (ID 13). Activate local lab "Amber" visuals and horns to alert lab ocupants of a contained exhaust ozone hazard. Provides local identification of a detected but "contained" ozone cabinet exhaust gas leak exceeding the alarm level. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and alarm recovery correction/s. 7 Ozone "Still" 15 Ozone "Still" Cabinet Exhaust 0.3 ppm X X X X X X Shutdown interlock applied by TGMS (dry contact interlock) to the upstream Ozone Generator (Utility matrix ID #14 and/or #16). Ozone generator/s (stop charging). No oxygen shutdown. TGMS shutdown interlock also applied affected to "ozone still" - (ID 15). Activate local lab "Amber" visuals and horns to alert lab ocupants of a contained exhaust ozone hazard. Provides local identification of a detected but "contained" ozone cabinet exhaust gas leak exceeding the alarm level. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Initiate local lab evacuation. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and alarm recovery correction/s. 8 Hydrogen Gas Cabinet 98 Hydrogen Gas Cabinet Exhaust 950 ppm X X X X X X X Shutdown interlock applied by TGMS (dry contact interlock) to Hydrogen gas cabinet controller (Utility matrix ID #98). Stopping Hydrogen flow to GIB and MBE tools. Pending safety / process requirements - Ozone generators and "stills" may also be interlocked. No oxygen shutdown. Activate local lab "Amber" visuals and horns to alert lab ocupants of a contained exhaust hazard. Provides local identification of a detected but "contained" hydrogen gas leak detected in the GIB cabinet exhaust exceeding the alarm level. Signal BMS to increase laboartory airflow to maximum - for alarm level gas detection in ambient breathing zone or within contained exhausts. Evaluate laboratory safety status (gas concentration) at the local area TGMS view screen (outside lab room at a safe location); to initiate investigation and alarm recovery correction/s. CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYTOXIC GAS MONITORING SYSTEMSAFETY REQUIREMENT SPECIFICATIONPAGE 2 of 2TOXIC GAS MONITORING SYSTEM Safety Requirement Specification (SRS) Physical Science Building - B87 - "CONQUEST - Moore Foundation" Laboratory TGMS Visualization Display/s Local B0042 Corridor + Remote Fire Command Center "Green" STEADY Visual TGMS Safety OK *Green Default with no System Alarm or Trouble "White" FLASHING Visual TGMS Trouble Exhaust Fail Equipment Fault TGMS Fault "Amber" FLASHING Visual - with Horn - TGMS Equipment Enclosure (Contained) Gas Alarm "Blue" FLASHING Visual - with Horn - TGMS Ambient Gas Alarm Interlock O3 Generator Controller ID 14 SHUTDOWN Ozone -stop charging- (dry contact) Interlock O3 Generator Controller ID 16 SHUTDOWN Ozone -stop charging- (dry contact) Interlock O3 /O2 Gas Cabinet "Still" Controller ID 13 SHUTDOWN Ozone -delivery- (dry contact) Interlock O3 /O2 Gas Cabinet "Still" Controller ID 15 SHUTDOWN Ozone -delivery- (dry contact) Interlock O2 Controller/s ID 96a and ID 96b SHUTDOWN Oxygen (dry contact) Interlock H2 Controller ID 98 SHUTDOWN Hydrogen (dry contact) Interlock O3 Controllers ID 14 + ID 16 and DUMP Ozone Stills ID 13 + ID 15 (dry contacts) TGMS Gas Alarm Signaling to BMS Provide MAXIMUM Airflow Ventialtion to Laboratory TGMS "Supervisory" Ambient Breathing Gas Alarm TGMS Signaling to Fire Alarm Panel TGMS / FAS Control Area EVACUATION TGMS "Supervisory" Contained Exhaust Gas Alarm TGMS Signaling to Fire Alarm Panel (No Evacuation) TGMS "Trouble" TGMS Alarm Bypass Mode TGMS Signaling to Fire Alarm Panel Comments # Alarm Location B87 Utility Matrix Equipment ID # Alarm "Cause" Alarm Level Visualize Alarms & Origin Local Laboratory B87 LED - Light Tower Visual / Audible Notifications Automated Interlocks TGMS Signaling to BMS TGMS Signaling to FAS Equipment / Enclosure - Exhaust Ventilation Trouble 9 O3 Generators Equipment Enclosure Exhaust 14 and 16 Ozone Generator cabinets Enclosure exhaust Ozone generators ID 14 and ID 16 -20% below expected normal setpoint X X X X Inadequate cabinet exhaust ventilation - Stop Ozone charging at both generators ID 14 and ID 16. Activate local Trouble visuals (Flashing white LEDs) Identify equipment trouble location at TGMS view node - Investigate and restore proper exhaust ventilation. (Note - dP alarm level setting based upon Owner experience) 10 Ozone "Still" 13 Ozone "Still" Cabinet Exhaust -20% below expected normal setpoint X X X X X Inadequate ozone "still" ID 13 cabinet exhaust ventilation - Interlock upstream Ozone generator/s (ID 14 and/or ID 16) to stop charging and Interlock "still" ID 13. Activate local Trouble visuals (Flashing white LEDs) Identify equipment trouble location at TGMS view node - Investigate and restore proper exhaust ventilation. (Note - dP alarm level setting based upon Owner experience) 11 Ozone "Still"15 Ozone "Still" Cabinet Exhaust -20% below expected normal setpoint X X X X X Inadequate ozone "still" ID 15 cabinet exhaust ventilation - Interlock upstream Ozone generator/s (ID 14 and/or ID 16) to stop charging and Interlock "still" ID 15. Activate local Trouble visuals (Flashing white LEDs) Identify equipment trouble location at TGMS view node - Investigate and restore proper exhaust ventilation. (Note - dP alarm level setting based upon Owner experience) Equipment - Safety Status 12 HPM Gas Cabinet "Gas Available" Warning Status Configuration Controller Dependent (Typical) 98 Integral Gas Cabinet Controller Warning Alerts include: Controller Warnings - Low pneumatic pressure Gas Manifold Warnings - High Delivery Pressure High Manifold Pressure Low Delivery Pressure High Purge Pressure Low Purge Pressure open contact X X Identify source of trouble at TGMS View node. Investigate cause of "warning" condition - locally at the hydrogen gas cabinet controller. 13 HPM Gas Cabinet "Gas Unavailable" Alarm Status Configuration Controller Dependent (Typical) 98 Integral Gas Cabinet Controller Shutdown Alarm Alerts include: Controller Alarms - Local cabinet controller - "Emergency Power Off" (EPO) Activated Cabinet Exhaust Ventilation Failure Gas Manifold Alarms - High Excess Flow High Manifold Pressure Low Delivery Pressure High Purge Pressure Low Purge Pressure open contact X X Identify source of trouble at TGMS View node. Investigate cause of "alarm" condition - locally at the hydrogen gas cabinet controller. H2 controller "Alarm condition/s" - locally interlocks (latches off & closes) the gas cabinet process outlet "Emergency Shutoff Valve" (ESOV). Requires local investigation and correction of alarm condition and a gas cabinet controller reset to restore operation. TGMS - Diagnostics / System "Availability" 14 Gas Sensor Fault Gas sensor - trouble diagnostic X X X X X X X X A "trouble" condition has occurred with a gas sensor or its transmitter - for ozone or hydrogen. This condition = the faulted gas sensor is "unavailable" - shutdown upstream gas source for the specifc gas detected. Identify source of trouble at TGMS View node. Investigate and correct fault 15 TGMS Logic / Module or Communication s Fault Controller / View Node fault diagnostic X X X X X X X X TGMS diagnostic fault - Investigate and correct fault. Pending failure source and location - this may result in a fail-safe shutdown (if hardware or communication failure occurs to logic controller and/or I/O interface). Shutdown HPM gas sources (ozone, hydrogen) until performance of the TGMS is restored. 16 Fire Alarm Panel "Sprinkler Flow" Signaling to TGMS PSB Fire Alarm "Sprinkler Flow" "closed contact"X X X X X X X X The PSB has an active Fire Alarm - as evidenced by activated FAS sprinkler flow signaling (dry contact) to the TGMS. Shutdown all ozone generation, Dump/Vent O3 storage and shutdown both H2 and O2 gas cabinets. Silence any and all actiive TGMS horns until FAS alarm signaling to TGMS is reset. TGMS - Periodic Gas Challenging / Testing (Bypass Mode) 17 TGMS Signal to FACP TGMS is in Fire Alarm Bypass Mode TGMS "voltage free" contact closure assigned to FACP X X X Provides a secured "TGMS to FAS Bypass" keyswitch to enable required periodic testing of assigned TGMS gas sensor points and other upsets - without signaling the FAS to issue an evacuation. TGMS issues a "Supervisory" signal to the FAS while the TGMS alarm bypass switch is active. The local lab "White" flashing visuals are also activated. CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYE0.0ELECTRICALLEGEND AND ABBREVIATIONSDATA/COMM ONE-LINE ELECTRICAL SYMBOL LEGEND POWER LIGHTING LIGHT FIXTURE DESIGNATION DETAIL ABBREVIATIONS FIRE ALARM TYPICAL DEVICE MOUNTING HEIGHTS DETAIL SECURITY B0062 A.8BCDC.2 A.6 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLAB LIGHTINGDEMOLITION PLANLAB LIGHTING DEMOLITION PLAN B0062 A.8BCDC.2 A.6 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLAB AREA POWER & DATADEMOLITION PLANLAB AREA POWER & DATA DEMOLITION PLAN CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYBUILDING ELECRICAL NFRASTRUCTURE POWER ONE LINE DEMOLITIONELECTRICAL INFRASTRUCTURE DEMOLITION POWER ONE LINE FD FCO A.8BCDC.2 A.6 1 C8 A510 C8 A510 233.544.75 6 7 8 8.715.13.14.23.35.5A.8BCDEFF.2GHC.2A.6H.6CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYBASEMENT LEVEL OVERALL ELECTRICALPLANBASEMENT LEVEL OVERALL ELECTRICAL PLAN MEN B0021 BM0001 7 8 8.7 G H H.6 G H H.6 7 8 8.7 MEN B0021 BM0001 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYBASEMENT LEVEL ELECTRICAL ROOM DEMOLITION AND PROPOSED PLANSBASEMENT LEVEL ELECTRICAL ROOM DEMOLITION PLAN BASEMENT LEVEL ELECTRICAL ROOM PROPOSED PLAN BC 10 BC 11 ELEC. B0085A BM0001 7 8 8.7 HBC 10 BC 11 ELEC. B0085A BM0001 7 8 8.7 HCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYMEZZANINE LEVEL ELECTRICAL ROOM DEMOLTIONAND PROPOSED PLANSMEZZANINE LEVEL ELECTRICAL ROOM DEMOLITION PLAN MEZZANINE LEVEL ELECTRICAL ROOM PROPOSED PLAN FD FCO A.8BCDC.2 A.6 2 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPROPOSED LAB POWER AND DATA PLANPROPOSED LAB POWER & DATA PLAN CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYBUILDING ELECTRICAL INFRASTRUCTURE PROPOSED POWER ONE LINE· · · CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYMBE POWER ONE LINEMBE ELECTRICAL POWER ONE LINE WIRE AND CONDUIT SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYAPRES POWER ONE LINEARPES ELECTRICAL POWER ONE LINE WIRE AND CONDUIT SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLEED AND APRESPOWER ONE LINESLEED POWER ONE LINE IPES POWER ONE LINE STM TRANSFER TUBE #1 ARPES TRANSFER TUBE #2 WIRE AND CONDUIT SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEPO CONTACTOR DIAGRAMGENERAL INFORMATION WIRING SCHEMATIC EQUIPMENT LAYOUT CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPANEL SCHEDULESPLS-EM-ARPES-LEED PLS-MBE-UPS PLS-MBE PLS-MBE-EQUIP FD FCO A.8BCC.2 A.6 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITY” TRANSFER TUBE WALL PENETRATION TRANSFER TUBE WALL PENETRATION CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEQUIPMENT LIST (1/2)Hex EQUIPMENT INFORMATION EQUIPMENT NAME:LOCATION: SUPPLIED BY: RIGGED AND MOUNTED BY: Company:Model: 1 MBE #1 MBE Lab B87 OWNER OWNER Veeco Gen10 2 MBE #1 Electronics Rack MBE Lab B87 OWNER OWNER Veeco - 3 MBE #2 (Future)MBE Lab B87 FUTURE FUTURE Veeco Gen10 4 MBE #2 Electronics Rack (Future)MBE Lab B87 FUTURE FUTURE Veeco - 5 Maple Top Table 30x72 (Qty 7)MBE Lab B87 OWNER OWNER Lista - 6 E-Beam Gun MBE Lab B87 OWNER OWNER Veeco - 6A E-Beam Power Supply MBE Lab B87 OWNER OWNER Veeco - 6B Robot/cluster module MBE Lab B87 OWNER OWNER Veeco - 7 Wet Bench MBE Lab B87 CONTRACTOR CONTRACTOR Reynoldstech - 8 Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 8a Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 9 Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 9a Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 10 Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 11 Storage Cabinets (Qty of 6)MBE Lab B87 OWNER OWNER Lista various 12 Bridge Crane MBE Lab B87 CONTRACTOR CONTRACTOR Budgit - 13 O3/O2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR -- 14 Ozone Generator Service Chase OWNER CONTRACTOR MKS/SEMOZON AX 8407C -3 15 O3/O2 Gas Cabinet (Future)Service Chase FUTURE FUTURE -- 16 Ozone Generator (Future)Service Chase FUTURE FUTURE MKS/SEMOZON AX 8407C -3 16a Ozone Controller Electronic Rack Ozone Rack OWNER OWNER -- 16b Ozone Destruct Service Chase OWNER CONTRACTOR -- 17 Vacuum Pumping Station - Portable MBE Lab B87 OWNER OWNER -- 18 MBE Control Computer MBE Lab B87 OWNER OWNER Veeco - 19 MBE Data Computer MBE Lab B87 OWNER OWNER Veeco - 20 MBE Other Computer MBE Lab B87 OWNER OWNER Veeco - 21 Cryo Pump 1 (Cooled by 60)ARPES OWNER OWNER Brooks Cryo-Torr 8 22 Turbo Pump 1 (Backed by 63)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 23 NEG Pump 1 ARPES OWNER OWNER Saes Capacitorr D-2000 24 He Lamp ARPES OWNER OWNER VG Scienta VUV5000 25 Microwave generator Rack 2 (Sources/Measurement)OWNER OWNER VG Scienta VUV5000 26 X-Ray Source has rack mounted UPS Rack 2 (Sources/Measurement)OWNER OWNER Specs AXR-50 27 HR-EELS Gun Rack 2 (Sources/Measurement)OWNER OWNER ARS LK5000M 28 Sclents R8000 Electron Analyzer Rack 2 (Sources/Measurement)OWNER OWNER VG Scienta R-8000 29 Closed Cycle Cryostat (CCC) 1 (cooled by 67)ARPES OWNER OWNER ARS CS204(P?)B 30 XYZ Stage see item 31 ARPES OWNER OWNER McAllister - 31 Manipulator Mk-V / Motors Rack 1 (LEED/ARPES Control)OWNER OWNER -- 32 RGA ARPES OWNER OWNER SRS RGA 100 33 Ion Gauge/Controllers (x3)Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 34 ARPES/LEED Control Computer MBE Lab B87 OWNER OWNER -- 35 ARPES/LEED Data Computer MBE Lab B87 OWNER OWNER -- 36 Cryo Pump 2 (Cooled by 61)LEED OWNER OWNER Brooks Cryo-Torr 8 37 Turbo Pump-2 (Backed by 64)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 38 NEG Pump-2 LEED OWNER OWNER Saes Capacitorr D-2000 39 ErLEED Rack 2 (Sources/Measurement)OWNER OWNER Specs ErLEED 100 40 RGA LEED OWNER OWNER SRS SRS 100 41 lonGauge/Controllers (x1)Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 42 Closed Cycle Cryostat (CCC) 2 (cooled by 68)LEED OWNER OWNER ARS CS204(P?)B 43 XYZ Stage LEED OWNER OWNER McAllister - 44 Manipulator Mk-VI / Motors Rack 1 (LEED/ARPES Control)OWNER OWNER Custom - 45 Roots Pump Service Chase OWNER OWNER -- 46 Data Acquisition Computer MBE Lab B87 OWNER OWNER -- 47 Mission Critical Laptop MBE Lab B87 OWNER OWNER -- 48 Cryo Pump 3 (Cooled by 62)IPES OWNER OWNER Brooks Cryo-Torr 8 49 Turbo Pump 3 (Backed by 64)Rack 3 (IPES)OWNER OWNER Pfeiffer Hi-Pace 700M 50 NEG Pump 3 IPES OWNER OWNER Saes Capacitorr D-2000 51 Cube Pump (Backing Turbo)IPES OWNER OWNER -- 52 Electron Gun Rack 3 (IPES)OWNER OWNER Kimball ELG-2/EGPS-1022 53 UPS Rack 3 (IPES)OWNER OWNER -- 55 Ion Gauge/Controllers (x1)Rack 3 (IPES)OWNER OWNER Brooks - 56 Temperature Controller/Heater Rack 3 (IPES)OWNER OWNER -- 57 RGA (IPES)Rack 3 (IPES)OWNER OWNER SRS SRS 100 58 Manipulator Mk-IV/Motors/xyz stage Rack 3 (IPES)OWNER OWNER -- 59 Bake out oven (tent)Lab OWNER OWNER -- 60 Cryo 1 Compressor (cools 21)Service Chase OWNER OWNER Brooks CTI 8200 61 Cryo 2 Compressor (cools 36)Service Chase OWNER CONTRACTOR Brooks CTI 8200 62 Cryo 3 Compressor (cools 48)Service Chase OWNER CONTRACTOR Brooks CTI 8200 63 Turbo 1 Backing Pump (cube pump) (Backs 22) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 64 Turbo 2 Backing Pump (cube Pump) (Backs 37) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 65 Turbo 3 Backing Pump (cube Pump) (Backs 49) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 66 Mono Turbo Pump (needs backing pump)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 300 67 CCC Compressor 1 (ARPES) (cools 29)Service Chase OWNER CONTRACTOR ARS ARS-4HW 68 CCC Compressor 2 (LEED) (cools 42)Service Chase OWNER CONTRACTOR ARS ARS-4HW 69 CCC Compressor 3 (IPES) (cools 69)Service Chase OWNER CONTRACTOR ARS ARS-4HW 71 Vacuum Pump - O3/O2 Gas Cabinet - Primary MBE 1 Service Chase OWNER CONTRACTOR Adixen ACP28G 72 Vacuum Pump - O3/O2 Gas Cabinet - Backup MBE 1 Service Chase OWNER CONTRACTOR Adixen ACP28G 73 Vacuum Pump - O3/O2 Gas Cabinet - Primary MBE 2 (Future)Service Chase FUTURE FUTURE Adixen ACP28G 74 Vacuum Pump - O3/O2 Gas Cabinet - Backup MBE 2 (Future)Service Chase FUTURE FUTURE Adixen ACP28G 75 Cryo Compressor - cooling O3 cabinet Service Chase OWNER CONTRACTOR ARS ARS-4HW CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEQUIPMENT LIST (2/2)Hex EQUIPMENT INFORMATION EQUIPMENT NAME:LOCATION: SUPPLIED BY: RIGGED AND MOUNTED BY: Company:Model: 76 Cryo Compressor - cooling O3 cabinet Service Chase OWNER CONTRACTOR ARS ARS-4HW 77 Rough Vacuum Pump - MBE #1 Main Turbo Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 78 Rough Vacuum Pump - MBE #1 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 79 Rough Vacuum Pump - MBE #1 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 81 Rough Vacuum Pump - MBE #2 Main Turbo Backing (Future)Service Chase FUTURE FUTURE Adixen ACP28G 82 Rough Vacuum Pump - MBE #2 Turbo diff pump source Backing (Future)Service Chase FUTURE FUTURE Adixen ACP28G 83 Rough Vacuum Pump - MBE #2Turbo diff pump source Backing (Future)Service Chase FUTURE FUTURE Adixen ACP28G 85 Rough Vacuum Pump - ARPES First stage helium lamp Service Chase OWNER OWNER Assuming Edwards XDS-10 85a Process Chamber Vacuum Pump (backs turbopump on process chamber)Service Chase OWNER CONTRACTOR Adixen ACP28G 86 Load Lock Vacuum Pump Service Chase OWNER CONTRACTOR Edwards ESDP12 87 Cryo-Compressor 1 (Connects to MBE 1)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 88 Cryo-Compressor robot (Connects to process chamber)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 89 Cryo-Compressor 2 (Connects to MBE 2) (Future)Service Chase FUTURE FUTURE Comes with the MBE: Brooks CTI 8200 90 XYZ stage 3 IPES IPES OWNER OWNER Mcalister - 91 Transfer Cart magnets and Motors Rack 1 (LEED/ARPES Control)OWNER OWNER N/A - 92 Closed Cycle Cryostat (CCC) 3 (cooled by 69)IPES OWNER OWNER ARS CS204(P?)B 93 Cryo Pump Compressor 4 (CP-4)Service Chase OWNER CONTRACTOR Brooks CTI 8200 94 Cryo Pump Compressor 5 (CP-5)Service Chase OWNER CONTRACTOR Brooks CTI 8200 95 Haskris H2O-H2O Hx Service Chase CONTRACTOR CONTRACTOR Haskris Custom 96 REMOVED 96a Oxygen Control Panel Service Chase CONTRACTOR CONTRACTOR -- 96b Oxygen Control Panel Service Chase CONTRACTOR CONTRACTOR -- 97 REMOVED 98 H2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR Used unit - 99 Nitrogen Gas Supply - high purity (cylinder provided and installed by owner)Service Chase CONTRACTOR CONTRACTOR -- 100 Nitrogen Gas Supply - industrial B0063 CONTRACTOR CONTRACTOR South-Tek Systems STS N2 2T or 4T 100a Nitrogen Tank B0063 CONTRACTOR CONTRACTOR South-Tek Systems GEN 90CS 101 REMOVED 102 Uninterruptable Power Supply ELEC Room CONTRACTOR CONTRACTOR -- 103 Cryo Pump - Transfer Chamber 1 CP-4 Transfer Chamber OWNER OWNER Brooks (CTI)Cryo-Torr 8 104 Cryo Pump - Transfer Chamber 2 CP-5 Transfer Chamber OWNER OWNER Brooks (CTI)Cryo-Torr 8 105 Turbo Pump Transfer Chamber 1 TP-4 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 105a Arpes Transfer Backing pump Service Chase OWNER OWNER Edwards nXDS15i 106 Turbo Pump Transfer Chamber 2 TP-5 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 107 Turbo Pump HE lamp -1 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 80m 108 Turbo Pump HE lamp -2 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 80m 109 IPES GM Tube IPES OWNER OWNER -- 110 Ion Gauge Controller Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 111 Ion Gauge Controller Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 112 Metal Evaporator 1 ME-1 ARPES OWNER OWNER -- 113 Metal Evaporator 2 ME-2 ARPES OWNER OWNER -- 114 Pirani Gauge (qty 8-10?) PG-1-X MBE Lab B87 OWNER OWNER -- 115 Webcams ( Qty.10-15)MBE Lab B87 OWNER OWNER -- 116 LED chamber Lights MBE Lab B87 OWNER OWNER -- 117 Bake Out Heater 1 BO-1 MBE Lab B87 OWNER OWNER -- 118 Bake Out Heater 2 BO-2 MBE Lab B87 OWNER OWNER -- 119 Bake Out Heater 3 BO-3 MBE Lab B87 OWNER OWNER -- 120 Bake Out Heater 4 BO-4 MBE Lab B87 OWNER OWNER -- 121 Bake out Heater Tape 1 BH-1 MBE Lab B87 OWNER OWNER -- 122 Bake out Heater Tape 2 BH-2 MBE Lab B87 OWNER OWNER -- 123 Bake out Heater Tape 3 BH-3 MBE Lab B87 OWNER OWNER -- 124 Bake out Heater Tape 4 BH-4 MBE Lab B87 OWNER OWNER -- 125 Electronics Racks (qty 3)MBE Lab B87 OWNER OWNER -- 126 MBE CHW dist. Panel MBE Lab B87 OWNER CONTRACTOR -- 126A MBE CHW dist. Panel (Future)MBE Lab B87 FUTURE FUTURE -- 127 STM transfer chamber roughing pump 1 B0063 OWNER OWNER Edwards nXDS15I 128 STM transfer chamber turbo pump 1 B0063 OWNER OWNER Pfeiffer HiPace 700M 129 STM transfer chamber cryo pump 1 B0063 OWNER OWNER Brooks Cryo-Torr 8 130 STM transfer chamber roughing pump 2 B0063 OWNER OWNER Edwards nXDS15I 131 STM transfer chamber turbo pump 2 B0063 OWNER OWNER Pfeiffer HiPace 700M 132 STM transfer chamber cryo pump 2 B0063 OWNER OWNER Brooks Cryo-Torr 8 133 STM transfer tube Ion gauge controllers (2x)MBE Lab B87 OWNER OWNER -- 134 STM TC Cryo Comp.1 (Cools 129)B0063 OWNER CONTRACTOR Brooks CTI 8200 135 STM TC Cryo Comp. 2 (Cools 132)B0063 OWNER CONTRACTOR Brooks CTI 8200 136 TGMS Panel MBE Lab B87 CONTRACTOR CONTRACTOR -- 137 REMOVED 138 REMOVED 139 Mono Turbo Pump backing pump Service Chase OWNER OWNER Assuming Edwards XDS-10 140 STM rotarty pump 1 B0063 OWNER OWNER Pfeiffer Duo10M 141 STM rotarty pump 2 B0063 OWNER OWNER Pfeiffer Duo10M 142 STM rotarty pump 3 B0063 OWNER OWNER Pfeiffer Duo10M 145 Scroll #3 Pump Service Chase OWNER OWNER Edwards nXDS15i 146 Scroll #5 Pump Service Chase OWNER OWNER Edwards nXDS15i 147 Scroll #6 Pump Service Chase OWNER OWNER Edwards nXDS15i 148 Super-Q Plus Water Purifier (4-bowl with pump)Lab CONTRACTOR CONTRACTOR Millipore Super-Q Plus (ZFSQ 115 P4) 149 Control Rack 1 (Leed and ARPES control)Lab OWNER OWNER Veeco - 150 Control Rack 1 (Source and Measurement)Lab OWNER OWNER Veeco - 151 Control Rack 3 (IPES Control)Lab OWNER OWNER Veeco - 152 Differential Pump Controler 1 Service Chase OWNER OWNER Veeco - 153 Differential Pump Controler 2 Service Chase OWNER OWNER Veeco - 154 Differential Pump Controler 3 Service Chase OWNER OWNER Veeco - 155 Differential Pump Controler 4 Service Chase OWNER OWNER Veeco - CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYSPECIALTY GAS AND VACUUM PIPING PROPOSED PLANBASEMENT - SPECIALTY GAS AND VACUUM PIPING PROPOSED PLAN CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYOXYGEN, OZONE, HELIUM AND FORELINEMBE SCHEMATICOXYGEN, OZONE, HELIUM, AND FORELINE MBE SCHEMATIC CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYCOMPRESSED AIR AND NITROGEN FLOW DIAGRAMCOMPRESSED AIR AND NITROGEN FLOW DIAGRAM SCALE: NOT TO SCALE PLUMBING SCHEDULESCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYNITROGEN GENERATOR SCHEDULE WATER PURIFIER SCHEDULE OXYGEN CONTROL PANEL SCHEDULE GAS CYLINDER MOUNT SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPLUMBING DETAILSEXISTING FLOOR DRAIN INFILL FORELINE PIPING SUPPORT UNDER CRANE RAIL NITROGEN PIPING TO DESICCATOR DETAILTYPICAL HELIUM COMPRESSOR INSTALLATION DETAIL FD FCO A.8BCDC.2 A.6 2 1 GENERAL ARRANGEMENT PROPOSEDBASEMENT - GENERAL ARRANGEMENT PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITY CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYB87A - SERVICE CLOSET ELEVATION B87A SERVICE CLOSET ELEVATION ROOM FINISH SCHEDULE ROOM # NAME FLOOR BASE WALL FINISH DOOR FRAMES CEILING COMMENTSNORTH SOUTH EAST WEST MAIN B87 LAB RESILENT TILE RESILANT BASE PAINT PAINT PAINT PAINT PAINT PAINT CIELING PAINT IS FOR TOUCH UP, NOT A WHOLESALE REPAINTING. TOUCH UP PAINT ON EAST WALL. REPAINT ENTIRE WEST WALL. B87A SERVICE CHASE RESILENT TILE RESILANT BASE PAINT PAINT PAINT PAINT PAINT PAINT SCALE: 1 1/2" = 1'-0"SCALE: 1 1/2" = 1'-0"SCALE: 3" = 1'-0"SCALE: 3" = 1'-0"CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 SCHEDULES802-923-3088WWW.HINGEINCVT.COM182 MAIN STREET, 2ND FL. BURLINGTON, VTB0063 SERVICE CHASE RESILENT TILE RESILANT BASE PAINT PAINT PAINT PAINT PAINT PAINT MATCH FLOOR TO EXISTING AFTER THE REMOVAL OF CONCRETE SLAB, SEE A1.0 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEQUIPMENT LIST (1/2)Hex EQUIPMENT INFORMATION EQUIPMENT NAME:LOCATION: SUPPLIED BY: RIGGED AND MOUNTED BY: Company:Model: 1 MBE #1 MBE Lab B87 OWNER OWNER Veeco Gen10 2 MBE #1 Electronics Rack MBE Lab B87 OWNER OWNER Veeco - 3 MBE #2 (Future)MBE Lab B87 FUTURE FUTURE Veeco Gen10 4 MBE #2 Electronics Rack (Future)MBE Lab B87 FUTURE FUTURE Veeco - 5 Maple Top Table 30x72 (Qty 7)MBE Lab B87 OWNER OWNER Lista - 6 E-Beam Gun MBE Lab B87 OWNER OWNER Veeco - 6A E-Beam Power Supply MBE Lab B87 OWNER OWNER Veeco - 6B Robot/cluster module MBE Lab B87 OWNER OWNER Veeco - 7 Wet Bench MBE Lab B87 FUTURE FUTURE Reynoldstech - 8 Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 8a Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 9 Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 9a Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 10 Desiccator MBE Lab B87 OWNER OWNER Terra Universal Smart Desiccator 1911-02C 11 Storage Cabinets (Qty of 6)MBE Lab B87 OWNER OWNER Lista various 12 Bridge Crane MBE Lab B87 CONTRACTOR CONTRACTOR Budgit - 13 O3/O2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR -- 14 Ozone Generator Service Chase OWNER CONTRACTOR MKS/SEMOZON AX 8407C -3 15 O3/O2 Gas Cabinet (Future)Service Chase FUTURE FUTURE -- 16 Ozone Generator (Future)Service Chase FUTURE FUTURE MKS/SEMOZON AX 8407C -3 16a Ozone Controller Electronic Rack Ozone Rack OWNER OWNER -- 16b Ozone Destruct Service Chase OWNER CONTRACTOR -- 17 Vacuum Pumping Station - Portable MBE Lab B87 OWNER OWNER -- 18 MBE Control Computer MBE Lab B87 OWNER OWNER Veeco - 19 MBE Data Computer MBE Lab B87 OWNER OWNER Veeco - 20 MBE Other Computer MBE Lab B87 OWNER OWNER Veeco - 21 Cryo Pump 1 (Cooled by 60)ARPES OWNER OWNER Brooks Cryo-Torr 8 22 Turbo Pump 1 (Backed by 63)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 23 NEG Pump 1 ARPES OWNER OWNER Saes Capacitorr D-2000 24 He Lamp ARPES OWNER OWNER VG Scienta VUV5000 25 Microwave generator Rack 2 (Sources/Measurement)OWNER OWNER VG Scienta VUV5000 26 X-Ray Source has rack mounted UPS Rack 2 (Sources/Measurement)OWNER OWNER Specs AXR-50 27 HR-EELS Gun Rack 2 (Sources/Measurement)OWNER OWNER ARS LK5000M 28 Sclents R8000 Electron Analyzer Rack 2 (Sources/Measurement)OWNER OWNER VG Scienta R-8000 29 Closed Cycle Cryostat (CCC) 1 (cooled by 67)ARPES OWNER OWNER ARS CS204(P?)B 30 XYZ Stage see item 31 ARPES OWNER OWNER McAllister - 31 Manipulator Mk-V / Motors Rack 1 (LEED/ARPES Control)OWNER OWNER -- 32 RGA ARPES OWNER OWNER SRS RGA 100 33 Ion Gauge/Controllers (x3)Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 34 ARPES/LEED Control Computer MBE Lab B87 OWNER OWNER -- 35 ARPES/LEED Data Computer MBE Lab B87 OWNER OWNER -- 36 Cryo Pump 2 (Cooled by 61)LEED OWNER OWNER Brooks Cryo-Torr 8 37 Turbo Pump-2 (Backed by 64)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 38 NEG Pump-2 LEED OWNER OWNER Saes Capacitorr D-2000 39 ErLEED Rack 2 (Sources/Measurement)OWNER OWNER Specs ErLEED 100 40 RGA LEED OWNER OWNER SRS SRS 100 41 lonGauge/Controllers (x1)Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 42 Closed Cycle Cryostat (CCC) 2 (cooled by 68)LEED OWNER OWNER ARS CS204(P?)B 43 XYZ Stage LEED OWNER OWNER McAllister - 44 Manipulator Mk-VI / Motors Rack 1 (LEED/ARPES Control)OWNER OWNER Custom - 45 Roots Pump Service Chase OWNER OWNER -- 46 Data Acquisition Computer MBE Lab B87 OWNER OWNER -- 47 Mission Critical Laptop MBE Lab B87 OWNER OWNER -- 48 Cryo Pump 3 (Cooled by 62)IPES OWNER OWNER Brooks Cryo-Torr 8 49 Turbo Pump 3 (Backed by 64)Rack 3 (IPES)OWNER OWNER Pfeiffer Hi-Pace 700M 50 NEG Pump 3 IPES OWNER OWNER Saes Capacitorr D-2000 51 Cube Pump (Backing Turbo)IPES OWNER OWNER -- 52 Electron Gun Rack 3 (IPES)OWNER OWNER Kimball ELG-2/EGPS-1022 53 UPS Rack 3 (IPES)OWNER OWNER -- 55 Ion Gauge/Controllers (x1)Rack 3 (IPES)OWNER OWNER Brooks - 56 Temperature Controller/Heater Rack 3 (IPES)OWNER OWNER -- 57 RGA (IPES)Rack 3 (IPES)OWNER OWNER SRS SRS 100 58 Manipulator Mk-IV/Motors/xyz stage Rack 3 (IPES)OWNER OWNER -- 59 Bake out oven (tent)Lab OWNER OWNER -- 60 Cryo 1 Compressor (cools 21)Service Chase OWNER OWNER Brooks CTI 8200 61 Cryo 2 Compressor (cools 36)Service Chase OWNER CONTRACTOR Brooks CTI 8200 62 Cryo 3 Compressor (cools 48)Service Chase OWNER CONTRACTOR Brooks CTI 8200 63 Turbo 1 Backing Pump (cube pump) (Backs 22) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 64 Turbo 2 Backing Pump (cube Pump) (Backs 37) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 65 Turbo 3 Backing Pump (cube Pump) (Backs 49) Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer HiCube 80 66 Mono Turbo Pump (needs backing pump)Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 300 67 CCC Compressor 1 (ARPES) (cools 29)Service Chase OWNER CONTRACTOR ARS ARS-4HW 68 CCC Compressor 2 (LEED) (cools 42)Service Chase OWNER CONTRACTOR ARS ARS-4HW 69 CCC Compressor 3 (IPES) (cools 69)Service Chase OWNER CONTRACTOR ARS ARS-4HW 71 Vacuum Pump - O3/O2 Gas Cabinet - Primary MBE 1 Service Chase OWNER CONTRACTOR Adixen ACP28G 72 Vacuum Pump - O3/O2 Gas Cabinet - Backup MBE 1 Service Chase OWNER CONTRACTOR Adixen ACP28G 73 Vacuum Pump - O3/O2 Gas Cabinet - Primary MBE 2 (Future)Service Chase FUTURE FUTURE Adixen ACP28G 74 Vacuum Pump - O3/O2 Gas Cabinet - Backup MBE 2 (Future)Service Chase FUTURE FUTURE Adixen ACP28G 75 Cryo Compressor - cooling O3 cabinet Service Chase OWNER CONTRACTOR ARS ARS-4HW CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYEQUIPMENT LIST (2/2)Hex EQUIPMENT INFORMATION EQUIPMENT NAME:LOCATION: SUPPLIED BY: RIGGED AND MOUNTED BY: Company:Model: 76 Cryo Compressor - cooling O3 cabinet Service Chase OWNER CONTRACTOR ARS ARS-4HW 77 Rough Vacuum Pump - MBE #1 Main Turbo Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 78 Rough Vacuum Pump - MBE #1 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 79 Rough Vacuum Pump - MBE #1 Turbo diff pump source Backing Service Chase OWNER CONTRACTOR Adixen ACP28G 81 Rough Vacuum Pump - MBE #2 Main Turbo Backing (Future)Service Chase FUTURE FUTURE Adixen ACP28G 82 Rough Vacuum Pump - MBE #2 Turbo diff pump source Backing (Future)Service Chase FUTURE FUTURE Adixen ACP28G 83 Rough Vacuum Pump - MBE #2Turbo diff pump source Backing (Future)Service Chase FUTURE FUTURE Adixen ACP28G 85 Rough Vacuum Pump - ARPES First stage helium lamp Service Chase OWNER OWNER Assuming Edwards XDS-10 85a Process Chamber Vacuum Pump (backs turbopump on process chamber)Service Chase OWNER CONTRACTOR Adixen ACP28G 86 Load Lock Vacuum Pump Service Chase OWNER CONTRACTOR Edwards ESDP12 87 Cryo-Compressor 1 (Connects to MBE 1)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 88 Cryo-Compressor robot (Connects to process chamber)Service Chase OWNER CONTRACTOR Comes with the MBE: Brooks CTI 8200 89 Cryo-Compressor 2 (Connects to MBE 2) (Future)Service Chase FUTURE FUTURE Comes with the MBE: Brooks CTI 8200 90 XYZ stage 3 IPES IPES OWNER OWNER Mcalister - 91 Transfer Cart magnets and Motors Rack 1 (LEED/ARPES Control)OWNER OWNER N/A - 92 Closed Cycle Cryostat (CCC) 3 (cooled by 69)IPES OWNER OWNER ARS CS204(P?)B 93 Cryo Pump Compressor 4 (CP-4)Service Chase OWNER CONTRACTOR Brooks CTI 8200 94 Cryo Pump Compressor 5 (CP-5)Service Chase OWNER CONTRACTOR Brooks CTI 8200 95 Haskris H2O-H2O Hx Service Chase CONTRACTOR CONTRACTOR Haskris Custom 96 REMOVED 96a Oxygen Control Panel Service Chase CONTRACTOR CONTRACTOR -- 96b Oxygen Control Panel Service Chase CONTRACTOR CONTRACTOR -- 97 REMOVED 98 H2 Gas Cabinet Service Chase CONTRACTOR CONTRACTOR Used unit - 99 Nitrogen Gas Supply - high purity (cylinder provided and installed by owner)Service Chase CONTRACTOR CONTRACTOR -- 100 Nitrogen Gas Supply - industrial B0063 CONTRACTOR CONTRACTOR South-Tek Systems STS N2 2T or 4T 100a Nitrogen Tank B0063 CONTRACTOR CONTRACTOR South-Tek Systems GEN 90CS 101 REMOVED 102 Uninterruptable Power Supply ELEC Room CONTRACTOR CONTRACTOR -- 103 Cryo Pump - Transfer Chamber 1 CP-4 Transfer Chamber OWNER OWNER Brooks (CTI)Cryo-Torr 8 104 Cryo Pump - Transfer Chamber 2 CP-5 Transfer Chamber OWNER OWNER Brooks (CTI)Cryo-Torr 8 105 Turbo Pump Transfer Chamber 1 TP-4 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 105a Arpes Transfer Backing pump Service Chase OWNER OWNER Edwards nXDS15i 106 Turbo Pump Transfer Chamber 2 TP-5 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 700M 107 Turbo Pump HE lamp -1 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 80m 108 Turbo Pump HE lamp -2 Rack 1 (LEED/ARPES Control)OWNER OWNER Pfeiffer Hi-Pace 80m 109 IPES GM Tube IPES OWNER OWNER -- 110 Ion Gauge Controller Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 111 Ion Gauge Controller Rack 1 (LEED/ARPES Control)OWNER OWNER Brooks - 112 Metal Evaporator 1 ME-1 ARPES OWNER OWNER -- 113 Metal Evaporator 2 ME-2 ARPES OWNER OWNER -- 114 Pirani Gauge (qty 8-10?) PG-1-X MBE Lab B87 OWNER OWNER -- 115 Webcams ( Qty.10-15)MBE Lab B87 OWNER OWNER -- 116 LED chamber Lights MBE Lab B87 OWNER OWNER -- 117 Bake Out Heater 1 BO-1 MBE Lab B87 OWNER OWNER -- 118 Bake Out Heater 2 BO-2 MBE Lab B87 OWNER OWNER -- 119 Bake Out Heater 3 BO-3 MBE Lab B87 OWNER OWNER -- 120 Bake Out Heater 4 BO-4 MBE Lab B87 OWNER OWNER -- 121 Bake out Heater Tape 1 BH-1 MBE Lab B87 OWNER OWNER -- 122 Bake out Heater Tape 2 BH-2 MBE Lab B87 OWNER OWNER -- 123 Bake out Heater Tape 3 BH-3 MBE Lab B87 OWNER OWNER -- 124 Bake out Heater Tape 4 BH-4 MBE Lab B87 OWNER OWNER -- 125 Electronics Racks (qty 3)MBE Lab B87 OWNER OWNER -- 126 MBE CHW dist. Panel MBE Lab B87 OWNER CONTRACTOR -- 126A MBE CHW dist. Panel (Future)MBE Lab B87 FUTURE FUTURE -- 127 STM transfer chamber roughing pump 1 B0063 OWNER OWNER Edwards nXDS15I 128 STM transfer chamber turbo pump 1 B0063 OWNER OWNER Pfeiffer HiPace 700M 129 STM transfer chamber cryo pump 1 B0063 OWNER OWNER Brooks Cryo-Torr 8 130 STM transfer chamber roughing pump 2 B0063 OWNER OWNER Edwards nXDS15I 131 STM transfer chamber turbo pump 2 B0063 OWNER OWNER Pfeiffer HiPace 700M 132 STM transfer chamber cryo pump 2 B0063 OWNER OWNER Brooks Cryo-Torr 8 133 STM transfer tube Ion gauge controllers (2x)MBE Lab B87 OWNER OWNER -- 134 STM TC Cryo Comp.1 (Cools 129)B0063 OWNER CONTRACTOR Brooks CTI 8200 135 STM TC Cryo Comp. 2 (Cools 132)B0063 OWNER CONTRACTOR Brooks CTI 8200 136 TGMS Panel MBE Lab B87 CONTRACTOR CONTRACTOR -- 137 REMOVED 138 REMOVED 139 Mono Turbo Pump backing pump Service Chase OWNER OWNER Assuming Edwards XDS-10 140 STM rotarty pump 1 B0063 OWNER OWNER Pfeiffer Duo10M 141 STM rotarty pump 2 B0063 OWNER OWNER Pfeiffer Duo10M 142 STM rotarty pump 3 B0063 OWNER OWNER Pfeiffer Duo10M 145 Scroll #3 Pump Service Chase OWNER OWNER Edwards nXDS15i 146 Scroll #5 Pump Service Chase OWNER OWNER Edwards nXDS15i 147 Scroll #6 Pump Service Chase OWNER OWNER Edwards nXDS15i 148 Super-Q Plus Water Purifier (4-bowl with pump)Lab FUTURE FUTURE Millipore Super-Q Plus (ZFSQ 115 P4) 149 Control Rack 1 (Leed and ARPES control)Lab OWNER OWNER Veeco - 150 Control Rack 1 (Source and Measurement)Lab OWNER OWNER Veeco - 151 Control Rack 3 (IPES Control)Lab OWNER OWNER Veeco - 152 Differential Pump Controler 1 Service Chase OWNER OWNER Veeco - 153 Differential Pump Controler 2 Service Chase OWNER OWNER Veeco - 154 Differential Pump Controler 3 Service Chase OWNER OWNER Veeco - 155 Differential Pump Controler 4 Service Chase OWNER OWNER Veeco - CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYARCHITECTURAL DETAILSB87A - UNISTRUT TABLE TYPICAL WALL MOUNTED SHELVING DETAIL B87A - GAS CYLINDER SUPPORT DETAIL B0063 - UNISTRUT TABLE ISOMETRIC BRACKET DETAIL SECTION B87 - UNISTRUT SUPPORT COLUMN B0063 - TRANSFORMER CEILING SUPPORT COATING SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC PLAN PROPOSEDBASEMENT - HVAC PLAN PROPOSED CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC PIPING PROPOSED PLANBASEMENT - HVAC PIPING PROPOSED PLAN MECHANICAL SCHEDULESCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYLABORATORY AIRFLOW CONTROL VALVE SCHEDULE FAN COIL SCHEDULE FILTER HOUSING SCHEDULE PRESSURE REDUCING VALVE DIFFUSERS REGISTERS AND GRILLES CONTROL VALVE SCHEDULE WATER CHILLER - LAB EQUIPMENT CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYWET BENCH DETAILSBASEMENT - WET BENCH DETAILS FRONT VIEW SIDE VIEW REAR VIEW DECK VIEW CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYMECHANICAL DETAILSB87A - PUMP EXHAUST DETAIL FAN COIL UNIT PIPING DETAIL TYPICAL ALL FUME HOOD EXHAUST CONNECTION DETAIL PIPE HANGER AND ROLLER DETAIL CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC CONTROL POINTS LISTSEQUENCE OF OPERATIONLABORATORY B87 CONTROL POINTS HARDWARE POINTS SOFTWARE POINTS SHOW ON GRAPHIC NOTES BI BO AI AO AV BV SCH TREND ALARM BACS EMCS DESCRIPTION STEAM LOAD SHED X BINARY NETWORK INPUT FROM EMCS CHILLED WATER LOAD SHED X BINARY NETWORK INPUT FROM EMCS TOTAL EXHAUST AIRFLOW (CFM) (B87)X X X LABORATORY B87 AIR CHANGE RATE (ACPH)X X X ROOM AREA B87 (SQUARE FEET)X X X ROOM CEILING HEIGHT (FEET) B87 X X FLOW OFFSET SETPOINT (CFM) B87 X X FLOW OFFSET ACTUAL (CFM) B87 X X X X X WET BENCH EXHAUST AIR VALVE STATUS (EV-A)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X X X X SASH OPEN 17" FOR 24 CONTINUOUS HOURS X WET BENCH EXHAUST AIR VALVE OCC/UNOCC COMMAND (EV-A)X X X X X GENERAL EXHAUST VALVE FLOW FEEDBACK (CFM) (EV-C)X X X GENERAL EXHAUST AIR VALVE STATUS (EV-C)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X GENERAL AIR VALVE OCC/UNOCC COMMAND (EV-C)X X SUPPLY AIR VALVE FLOW FEEDBACK (CFM) (SV-A)X SUPPLY AIR VALVE STATUS (SV-A)X X 10% FLOW DEVIATION FROM SETPOINT X TRI-STATE ALARM X VALVE COMMAND AND FEEDBACK MISMATCH (JAM) X LOW DIFFERENTIAL PRESSURE (VIA SWITCH) SUPPLY AIR VALVE POSITION COMMAND (CFM) (SV-A)X X X SUPPLY AIR VALVE MINIMUM AIRFLOW SETPOINT (CFM) (SV-A)X X SUPPLY AIR VALVE MAXIMUM AIRFLOW SETPOINT (CFM) (SV-A)X X REHEAT COIL LEAVING AIR TEMPERATURE (SV-A)X X X REHEAT COIL VALVE POSITION COMMAND (%) (SV-A)X X X 5 DEG F CHANGE ACROSS COIL WITH VALVE COMMANDED CLOSED X SUPPLY AIR VALVE FLOW FEEDBACK (CFM) (SV-C)X SUPPLY AIR VALVE STATUS (SV-C)X X 10% FLOW DEVIATION FROM SETPOINT X TRI-STATE ALARM X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X SUPPLY AIR VALVE POSITION COMMAND (CFM) (SV-C)X X X SUPPLY AIR VALVE MINIMUM AIRFLOW SETPOINT (CFM) (SV-C)X X SUPPLY AIR VALVE MAXIMUM AIRFLOW SETPOINT (CFM) (SV-C)X X REHEAT COIL LEAVING AIR TEMPERATURE (SVV-C)X X X REHEAT COIL VALVE POSITION COMMAND (%) (SVV-C)X X X 5 DEG F CHANGE ACROSS COIL WITH VALVE COMMANDED CLOSED X FAN COIL START/STOP (FCU-A) (FUTURE)X FAN COIL STATUS (FCU-A) (FUTURE)X FAN COIL UNIT SPEED SIGNAL (FUTURE)X FAN COIL UNIT OPERATING SPEED (FUTURE)X FAN COIL CHW CONTROL VALVE COMMAND (FCU-A) (FUTURE)X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-A) (FUTURE)X FAN COIL START/STOP (FCU-B)X X X X FAN COIL UNIT SPEED SIGNAL X X X FAN COIL UNIT OPERATING SPEED X X X X FAN COIL STATUS (FCU-B)X X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-B)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-B)X X X X X SPACE TEMPERATURE SETPOINT, HEATING (B87)X X X SPACE TEMPERATURE SETPOINT, COOLING (B87)X X X SPACE TEMPERATURE (NORTHERN B87)X X X +/- 4 DEGREES F FROM SETPOINT X SPACE TEMPERATURE ADJUSTMENT (NORTHERN B87)X X SPACE TEMPERATURE (SOUTHERN B87)X X X +/- 4 DEGREES F FROM SETPOINT X SPACE OCCUPANCY (NORTHERN B87)X X X X SPACE OCCUPANCY (SOUTHERN B87)X X X X SPACE OCCUPANCY, MINIMUM OCCUPANCY SETPOINT (B87)X X TOTAL EXHAUST AIRFLOW (CFM) (B87A)X LABORATORY B87A AIR CHANGE RATE (ACPH)X X X ROOM 87A (SQUARE FEET)X X X ROOM CEILING HEIGHT (FEET) (B87A)X X B87A ENCLOSURE EXHAUST VALVE FLOW FEEDBACK (CFM) (EV-B)X X X B87A ENCLOSURE EXHAUST AIR VALVE STATUS (EV-B)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X B87A EXHAUST AIR VALVE OCC/UNOCC COMMAND (EV-D)X X B87A GENERAL EXHAUST VALVE FLOW FEEDBACK (CFM) (EV-D)X X X B87A GENERAL EXHAUST AIR VALVE STATUS (EV-D)X X VALVE COMMAND AND FEEDBACK MISMATCH (JAM)X TRI-STATE ALARM X LOW DIFFERENTIAL PRESSURE (VIA SWITCH)X B87A GENERAL EXHAUST AIR VALVE OCC/UNOCC COMMAND (EV-D)X FAN COIL START/STOP (FCU-C)X X X X FAN COIL STATUS (FCU-C)X X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-C)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-C)X X X X X FAN COIL START/STOP (FCU-D)X X X X FAN COIL STATUS (FCU-D)X X X X X FAN COIL CHW CONTROL VALVE COMMAND (FCU-D)X X X X FAN COIL CHW DISCHARGE AIR TEMPERATURE (FCU-D)X X X X X CHILLER INLET PROCESS CHILLED WATER X X X MONITORING ONLY X CHILLER OUTLET PROCESS CHILLED WATER X X X MONITORING ONLY X CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYHVAC CONTROLAIRFLOW SEQUENCESMinimum Ventilation Rates Calculations Room Room Dimensions Cornell University Laboratory Standards 2010 New York State Code Minimum ASHRAE 62.1 2007 Supply Air Minimum ASHRAE 62.1 2007 Exhaust Air Minimum Occupied Airflow (8 ACH) Unoccupied Airflow (4 ACH) Occupied Airflow (6 ACH) Unoccupied Airflow (3 ACH)Hibernation Airflow Vacant AirflowArea (sq. ft.) Height (feet) Volume (cu.ft.) # of people Airflow # of people Airflow Airflow (ach) (cfm) (ach) (cfm) (ach) (cfm) (ach) (cfm) (ach) (cfm) (ach) (cfm) (cfm) (ach) (cfm) (ach) (cfm) (ach) B87 1,020 15.9 16,193 8 2,159 4 1,080 6 1,619 3 810 N/A N/A 1 270 30.6 612 2.3 25.5 439 1.6 1,020 3.8 B87A 154 16.0 2,464 8 329 4 164 6 246 3 123 N/A N/A 1 41 4.6 92 2.3 3.9 66 1.6 154 3.8 See Cornell University standard detail 3.7.1 for explanation of derivation of values shown here CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPLUMBING PROPOSED PLANBASEMENT - PLUMBING PROPOSED PLAN EXISTING PLUMBING LEGEND CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYCOMPRESSED AIR AND NITROGEN FLOW DIAGRAMCOMPRESSED AIR AND NITROGEN FLOW DIAGRAM SCALE: NOT TO SCALE PLUMBING SCHEDULESCORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYNITROGEN GENERATOR SCHEDULE WATER PURIFIER SCHEDULE OXYGEN CONTROL PANEL SCHEDULE GAS CYLINDER MOUNT SCHEDULE FD FCO A.8BCDC.2 A.6 2 1 CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPROPOSED LAB POWER AND DATA PLANPROPOSED LAB POWER & DATA PLAN CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYMBE POWER ONE LINEMBE ELECTRICAL POWER ONE LINE WIRE AND CONDUIT SCHEDULE CORNELL UNIVERSITYPHYSICAL SCIENCE BUILDINGCONQUEST-MOORE FOUNDATIONKEY A.2JG D 1 3 5 7 PHYSICAL SCIENCE BUILDINGCORNELL UNIVERSITYPANEL SCHEDULESPLS-EM-ARPES-LEED PLS-MBE-UPS PLS-MBE PLS-MBE-EQUIP